Automotive Technicians Technical Discussion and Fixes for Aug 22, 2012

Join Now

Prev	Professional Automotive Repair Technical Discussions for August 22, 2012 International Automotive Technicians' Network (iATN) - Members Only	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for All Makes and Models

	Help Request	Answers
	2000 Acura RL Premium 3.5L Srs VIN: JH4KA9663Y when i clear the code the light goes out it blinks twice then comes back on the first time i had to drive it and then after that it comes right back on the trouble im haveing is that it wont give me codes when i jump the srs conector under the glove box it doe...	View
	1997 Audi A8 Quattro 4.2L Misfire, MIL Lamp on VIN: WAUBG84D6V Hello group Got audi here came in with lots of problems,running bad and parts on seat. He asked us to replace bad vacuum hoses thathe decided he could not. We removed intake and replace the hoses under intake intake gaskets and few other hoses we found bad. T...	View
	1998 Audi A6 Quattro 2.8L windows, interior lights VIN: WAUBA24B6W Hello everyone. I have an A6 here with no interior lights, and all power windows inop. I checked codes in the central locking module using a Launch X431 and there were about three pages. Erased codes and immediately 01570 returned: Ignition Switch Terminal 15 ...	View
	1999 Audi A4 1.8L Cuts out VIN: WAUGB28D5X Hail all ye Audi techs!! I have a 99 audi a4 quattro with a p1545 code for the throttle valve. it idles poorly and at about 1500 rpm it cuts out however you can push past it by feathering and keep the rpm up. the p1545 code comes back every time. I have repla... Trouble codes: P1545	View
	2004 Audi TT Quattro 3.2L Stall VIN: TRUUF28NX4 customer says it will stall intermitently usualy after a hot restart. the service writer had it happen to him once. with gauges on fuel lines it has never happened. watching the fuel pump waveform there are some low peaks pressur is about 3 psi. low. this is a...	View
	2006 Audi A4 2.0L MIL Lamp on VIN: WAUDF78E16 the car sets dtc p2293 when accerating under load. I can not get the fuel rail pressure to build past 90bar. I am starting to believe i have the wrong engine installed but dealer tells me they are all the same parts used. The car orignally came with a BPG engi... Trouble codes: P2293	View
	2003 BMW 760Li 6.0L Electronic Height Control VIN: WBAGN83403 This vehicle leaks down in the LH rear suspension and we believe that the shock unit is leaking. Any sugesstions on how to isolate and prove the leak is in the shock unit. I'm hesitant to put an $1800.00 shock unit on without being able to prove that the leak ...	View
	2003 Buick LeSabre Custom 3.8L High RPM VIN: 1G4HP52K93 I have a problem with a high RPM after the engine warms up. The idle speed is high in gear or with the A/C on. When idle is steady I can controll the idle speed with the IAC functional test. After warmed the idle speed sits between 900-1100 RPM and can fluctua...	View
	1968 Chevrolet Camaro 6.5L engine VIN: 124378L311 Hey all, I got a fun one here. We have a customer who is making a '68 Yenko Camaro clone car and he was having engine problems with it. THe engine is a factory correct'68 427. It has square port heads, factory aluminum intake, factory Holley carb, factory exha...	View
	2000 Chevrolet Astro 4.3L Poor Idle Quality, Hesitation, Stall, Misfire, MIL Lamp on VIN: 1GCDM19W4Y The new distributor was installed 8 months ago and it was running good then, 0 CMP retard according to notes. Customer stated that the recent issue happened all of a sudden at a stop light. This van came in with a misfire and P0300, a problem it had before. T... Trouble codes: P0300	View
	2002 Chevrolet Trailblazer LS 4.2L Cuts out, MIL Lamp on VIN: 1GNDT13S02 Hi guys. This was on a post I thought I had fixed. Intermittent ses light combined with pedal position sensor problems resulting in power loss mode. I found out about the fan clutch problem spiking and replaced it. Seemed good for a week and came back. Warrant... Trouble codes: P1271, P1275, P1280	View
	2003 Chevrolet Silverado 3500 8.1L Fuel Gauge VIN: 1GBJK34G33 Hi Guys, I don't post very often I usually just read other folks posts & fixes. This one I can't get done and need some help please. This truck came in, no start. Checked fuel pressure no pressure,I jumped fuel pump relay pump won't run so I changed the pump. ...	View
	2006 Chrysler PT Cruiser 2.4L Compressor VIN: 3A4FY48B56 Employee was using the A/C one day during the rain, shut it off because it was getting too cold and went to use it later on but the compressor would not run. A/C indicator light on dash works. Fuse is OK. Gauges indicate system has a charge. Solus tells me the...	View
	2006 Chrysler PT Cruiser Touring 2.4L brake warning VIN: 3A4FY58B06 I have this PT cruiser with a brake light warning lamp constantly on non abs, ive disconnected fluid lvl sensor still stays on, disconnected the parking brake switch still stays on, I tried both at the same time still stays on, I tried a new brake fluid lvl sw...	View
	1995 Dodge Dakota 3.9L 3-4 shift VIN: 1B7GG23X6S Problem mainly after cold soak for first 10 to 15 miles. Truck is sluggish on start up, seems short of power, removed o2 sensor to check cat, no difference, when it gets to 4th gear it drops in and out of 4 th, seems to be thermally related, because after 15 m...	View
	2002 Dodge Intrepid SE 2.7L Hesitation, Misfire, MIL Lamp on VIN: 2B3HD46R12 thanks for any help the problem with this car is a bad hesitation when taking off. looked at misfire data shows miss on 2-4-6 cylinders. swapped front o2 no change! what am i missing? the new o2 sensors are bosch! thanks in advance! greg Trouble codes: P0152, P0132	View
	2007 Dodge Ram 3500 ST 5.9L A/C compressor VIN: 3D7MX48C57 Please help I am stumped here and need to know what steps to take next! I had this truck with an inop compressor clutch which I tested and found to be a faulty clutch. Replaced compressor and sent down the road to quick lube to charge because my machine was no...	View
	2008 Dodge Sprinter 2500 3.0L boost contrl VIN: WD0PE84588 I have a sprinter that is going into engine limp mode and setting a low boost pressure code 2359-001. I also have an EGR code for implausible EGR cooler temp. signal that randomly sets so I removed EGR valve cleaned and ensured proper operation,(Thought it may...	View
	2009 Dodge Charger R/T 5.7L key switch this police car is a column shift with a key start win module at times key will not go to lock so you are unable to remove key it has been to dodge dealer ,they say steering column needs replaced at a cost of 2500.00 dollars i have been able to run shifter thr...	View
	1996 Ford F-350 XL 7.3L Low Psi Oil VIN: 1FTJW35F5T Customers truck shut down going road. Will not build low pressure oil, will not supply oil to the HP reservoir. I can fill HP reservoir and it will start and run until it empties reservoir. Over filled oil 2.5 gal.Unplugged IPR and spun engine, no psi or oil t...	View
	2004 Ford F-150 FX4 5.4L Hesitation, Surge, Cuts out, MIL Lamp on VIN: 1FTPX14564 vehicle came in with rough idle, hesitation, cutting off and no power at all. it starts up fine no rattle in engine. scan the vehicle and came up with three codes P0010, P0020, and P0102 the two codes have to deal with the variable cam timing solenoid and the ... Trouble codes: P0010, P0020, P0102	View
	2004 Ford F-150 XL 4.6L steering pump Thanks in advance, we have this vehicle that customer complaint was load steering pump. replaced it with napa rebuild followed directions on removing air from system, still has loud whine. one post on IATN said that you are lucky if you get a pump that does no...	View
	2006 Ford F-250 Super Duty XLT 5.4L Unknown VIN: 1FTNF20536 truck will idle between 750 and 800 but when you drive it and slow to stop it will cut off, someone had cleared the codes but it did have a po300 when it came in . i have cleared the code and driven the truck and so far no codes . i have checked for vacum leak...	View
	1998 GMC Sonoma SL 2.2L 4th gear VIN: 1GTCS1446W hi guys, I am not a transmission specialist by far and am trying to find the problem on my truck to no avail. When i am on the highway cruising at a constant speed and the throttle is steady (10- 20%), the truck will shift into 4th gear and then slip out to 3...	View
	2001 Honda Accord EX 3.0L Srs VIN: 1HGCG16501 At the time we were replacing everything I had purchased two new airbags, seat belts, and SRS ecu from a seller on EBay. These codes have been there ever since, except for 9-4, that one is recent. Every now and again it annoys me enough to try something differ...	View
	2003 Honda Civic EX 1.7L Poor Idle Quality, Hesitation, Surge VIN: 2HGES25703 Honda guys out there can you steer me in the right direction please? I have a 2003 Honda Civic with a 1.7 Vtec. Customers concern is when the car is started they go to take off and the car falls flat on it's face no power then it returns to normal. It does not...	View
	2004 Hyundai Sonata GLS 2.7L Engine VIN: KMHWF35H64 Hello, all. Vehicle came in with extensive engine damage due to a broken timing belt tensioner and belt. Vehicle has 300k plus miles so we installed a used engine per customer request. customer came back a couple days later with temperature guage in the red, s...	View
	2006 Infiniti M35 Sport 3.5L Compressor VIN: JNKAY01E56 This vehicle came in for no a/c, compressor not engaging, checked refrigerant charge, found low, evac and recharged, checked for codes in climate control #25 sunload sensor, replaced sensor, self test now shows OK,with scanner have no command for a/c request, ...	View
	2003 Jaguar X-Type 3.0L Master Cyl. VIN: SAJEA51C13 First thanks to all that reply. Car came to me with master that was leaking into booster. it is 100% better but pedal to me has excessive travel and feels like it pumps up and fades. I have bleed numerous times, r/r,l/r,r/f,l/f and diagnally,as repair informat...	View
	2000 Jeep Cherokee Sport 4.0L Poor Idle Quality, Hesitation, Surge, Cuts out, Misfire VIN: 1J4FF48S0Y This came from another shop that couldn't fix it. Runs bad. We have replaced the coil pack twice, crank and cam sensors once. We have synced the timing, replaced the ASD relay, replaced the oxygen sensors and finally the computer and has it programed for this ... Trouble codes: P1391 (CMP or CNK sensor intermittant), P1351 (Ign coil 1 primary circuit), P1352 (Ign coil 2 Primary circuit), P1353 (Ign coil 3Primary crcuit)	View
	2003 Land Rover Range Rover HSE 4.4L Transmission VIN: SALMB11463 Hi guys, This is actually a customer of ours that asked us to try and sell for them. We have done most of the maintenance and repair work to this vehicle. The car has been sitting for close to a year and we needed to put a battery in it and some fresh gas....	View
	2002 Lincoln LS 3.9L Stall VIN: 1LNHM87A62 the car stumbles or dies when making a turn at slow speed. I have checked everything I can think of. any ideas	View
	2004 Lincoln LS 3.0L Poor Idle Quality, Hesitation VIN: 1LNHM86S84 Vehicle exhibited low idle, driver would need to feather throttle at stop light or around corner or would quit. Would immediately restart. Also exhibited condition with intermittent lack of power at hwy speeds. Would lose power, lift off accelerator power woul...	View
	2005 Lincoln Navigator 5.4L Hesitation, Surge, Cuts out, No throttle response VIN: 5LMFU28595 HELP ! Vehicle can to us from the dealer, where it was taken for a transmission service. While there the customer was told it needed 3 coils and spark plugs. WE replaced the 3 motorcraft coils and installed 8 motorcraft plugs. On road test we noted that it is ...	View
	2005 Lincoln LS Luxury 3.0L a/c temp VIN: 1LNHM86S95 the a/c system is full and cools well at times,after running a/c for a while the air is not cold or on very hot days the air is not cool enough,the vehicle has a new electronic heater control valve.	View
	1997 Mercedes-Benz E420 4.2L Unsure VIN: WDBJF72F3V Hello and thank you for helping with our requests. On this Mercedes we have a pop at almost full right hand turn when you're backing out of the driveway.It sometimes can pop when you go to take away from the stop. The noise is definitely coming from the front....	View
	2002 Mercedes-Benz ML320 3.2L Misfire VIN: 4JGAB54E72 Help I have this car for about a week for misfire problem on cyc. 2,3,&5 I have checked for pressure test average of 170 psi. Check injector pulse cyc. 3 and 5 die out within 2 mins test for continuity on both wires they checked out good. Changed mass air flow... Trouble codes: P2056, P0305 (p2053-), P2053 (p0303-), P0303	View
	2010 Mercedes-Benz Sprinter 2500 3.0L Poor Idle Quality, Misfire VIN: WDZPE7CC4A I am leaning towards replacing the engine control module as it is the only component left that I can think of to cause a misfire at cyl. 6. Compression is good, injector is known good, fuel pressure is within spec. and of course I have a fault code for an inte... Trouble codes: 10E70, 15A50, 15600	View
	2008 Mercury Sable 3.5L Strut? VIN: 1MEHM40W38 Vehicle makes a pop/clunk/thunk kind of a noise going over bumps at any speed. We acted on a TSB that recommended greasing the strut bumper which is part of the rubber bellows. That reduced the noise, but did not eliminate it. We then replaced the upper strut ...	View
	1989 Nissan Pathfinder SE 3.0L intake/head gasket VIN: JN8HD16Y1K Hey techs first time asking for a little advice here. I'll try to keep it short. I recently inherited this pathfinder and at first look did not see anything wrong with it. The only thing I knew about it is that it had been sitting since 2009 and driven sporadi...	View
	2000 Nissan Quest GLE 3.3L Stall VIN: 4N2XN11T3Y Hi this quest came in with a p0100 mass airflow circuit so I fixed the wiring and code never came back, short term and long term fuel trim are between negative 10 to full 25 percent yet t is still running lean. The cats are not clogged. If you all need any mor...	View
	2003 Nissan Sentra GXE 1.8L MIL Lamp on, no throttle response VIN: 3N1CB51D93 This is the third occurence in a couple months, when problem occurs, gauges all drop out and has no throttle response. I have not yet got it to do it for me, this is customers description. when it happens, he just shut vehicle off, restarts, and it will be fin... Trouble codes: P0462, U1000, U1001	View
	2005 Nissan Armada LE 5.6L airbag VIN: 5N1AA08A65 Hi Nissan Techs, We have an '05 Armada here that has 2 problems that may or may not be related. The client has had the brakes lock up twice after a panic stop but only under high ambient temp conditions. He disconnects the battery and the brakes unlock. Some ...	View
	2007 Nissan Altima S 2.5L braking VIN: 1N4AL21E07 car came in for "grabbing feel" to brake while stopping. on test drive the pedal is very touchy and will stop on a dime like it is getting too much power assist. there are no codes, no noises and linings are at least half remaining.	View
	2005 Scion xA 1.5L MIL Lamp on VIN: JTKKT62435 hi everyone got a head scratcher here. got this scion with typical p0012 code but this time when you try to activate oil control valve with scanner nothing happens. hook up 9 volt battery and engine instantly stalls. Ohmed out wires extensively to pcm and no p... Trouble codes: P0012	View
	2006 Toyota Tacoma Pre Runner 4.0L MIL Lamp on VIN: 3TMKU72N56 We have this tacoma with a hard p0018, sets within 5 min. Alldata shows the theory on how this code sets, but the only outcome listed is a jumped chain, or ECM problem. The engine does run quite well, with a bit of timing chain rattle here and there at idle, h... Trouble codes: P0018 (cam crank correlation bnk 2 sensor A)	View
	1987 Volkswagen Scirocco 16-Valve 1.8L Cooling Systems VIN: WVWCB0531H Never thought a 25 year old would kick my hiney, but this one is getting the best of me. First off, the car is exceptionally clean, completely stock with NO mods, near show perfect and just a nice car all around. It came in about 2 months ago with a leaky wate...	View
	1999 Volkswagen Passat GLS 1.8L door locks VIN: WVWMA63B9X The trouble is that the doors will not open by beeper or key. On one occasion opened the right rear door but the days passed and he did not want to open any, either inside or outside. I open them to install new locks. thanks for help me.	View
	2001 Volvo C70 2.3L battery VIN: YV1NC53D81 The battery goes dead. I have a draw on C8 and believe it is the IPC. I had got another one and now the draw comes and goes with the new (used) IPC. I want to know if the clock and miles on the IPC is on all the time. Is that normal opp? I can pull the fuse an...	View
	2004 Volvo XC70 2.5L No Start, Stall VIN: YV1SZ59H84 Customer complaint of intermittant stall and restart. Came into the shop with the above codes (really concerned about the ECM control module fault) Cleared codes and performed throttle body adaptation and took for a test drive. Drove great, parked in shop, got... Trouble codes: 260A, 261A, 400C, 130A, 6814 (Turbocharger control signal too high), 981A	View

Fixes & Summaries for All Makes and Models

	Fix/Summary	Answers
	2007 Acura TL 3.2L MIL Lamp on VIN: 19UUA66207 Thank you for all the replies. I came to thr conclusion that the valve adjustment needed to be checked and compression and also for bent rod. I explained this to the customer and they decided to take it to the dealer. So to make a long story short the dealer h... Trouble codes: P2279 (Air Intake System Leak).	8
	2005 Audi A4 Quattro 2.0L Variable exhaust cam VIN: WAUDF68E25 Thank you for your responses gentleman. Great site Charles, very informative. After having looked at all the parts illustrations and speaking with another Audi dealer it appears these piston rings are only sold as part of the rear cover for this engine. The 3....	5
	1997 BMW 528i 2.8L Temperature guage VIN: WBADD6326V The repair was two fold. After reading all help email, I double checked all possibilties. When refilling cooling system I used a system evacuator to remove air. I also found the three stage auxiliary fan in front of radiator to be faulty.	22
	2004 BMW X3 2.5i 2.5L No Start VIN: WBXPA73474 Thanks for all the help, I ended up sending this one to the dealer to confirm a bad DME. Trouble codes: 2796 (Throttle adapt values incorect), 27C7, 28B2.	6
	1999 Buick Regal GS 3.8L No Start VIN: 2G4WF5213X Some replies said to reckeck all powers and grounds which I had already done. Others said to ck. the wiring and recheck my techs work to see if he caused the problem. Again I had already checked and ruled these possibilities out. The responses that said yes, t...	14
	2002 Chevrolet Silverado 2500 HD 6.6L Compressor Inop VIN: 1GCHK23132 Thank you for the help but the truck still is broke. My friend has been to busy to go back and get the computer re-flashed. Come to find out it was only 2 weeks since he had the flash done. I am confident it is ecm related. I will try to update when he gets th...	5
	2004 Chevrolet Colorado LS 2.8L MIL Lamp on VIN: 1GCCS19844 So I called him a 3rd time last week and he said that he had looked at the blower not working before washing and changing filter. He pulled each fuse 1 by 1. so I checked codes again and a p1682 popped up. I then went to Blue connector PCM and checked Pin 20, ... Trouble codes: P2101 (Control Module Performance), P1516 (Tac Module Performance).	3
	2008 Chrysler Sebring Touring 2.7L noise VIN: 1C3LC55R38 Customer has not returned and I have not heard anything from him sorry to report that I have not made any progress on this vehicle. Thanks for all the replies.	14
	1999 Ford F-250 Super Duty Lariat 7.3L Power Locks VIN: 1FTNX21F0X THANKS FOR ALL THE REPLIES. FOUND THE MAIN DOOR LOCK SWITCH FAULTY, REPLACED SWITCH AND ACTUATORS, PROBLEM SOLVED.	10
	2000 Ford F-350 Super Duty Lariat 7.3L Engine VIN: 1FTSW30F1Y Hello everyone, The customer has taken the vehicle due to the fact that the invoice went from the PCM to the high pressure oil pump; but at least all codes initially were out but only had a Turbo code (probably due to the engine oil leak bypassing the turbo) ...	4
	2007 Ford F-550 Super Duty XL 6.0L no power, VIN: 1FDAX56P37 thank you alll for all the help i found out from ford information that 20 rpm drop on a power balance test is enough to say there is a bad injector.we concluded with 3 injector being bad customer picked up the vehicle we still did not change the injectors yet....	20
	2008 Ford Mustang GT 4.6L battery draw VIN: 1ZVHT82H08 THANK FOR ALL OF THE SUGGESTIONS. AFTER DISCONNECTING THE BATTERY AND REPAIRING THE CONNECTOR AT THE SMART JUNCTION BOX. I HAD THE CAR FOR A WEEK. I LET THE CAR SIT OVER THE WEEKEND AND IT STARTED WITH NO PROBLEM. BATTERY DRAW AFTER CONTROLS WENT TO SLEEP WAS ...	10
	2008 Ford Escape XLT 3.0L Unknown VIN: 1FMCU93168 We replaced both front axles and vibration is now gone. Thanks all for all of the suggestions.	12
	2001 Lexus ES300 3.0L Soft pedal and poor braking VIN: JT8BF28G61 Well I ended up putting a right rear brake hose on and bleeding everything again and that fixed it. With the pedal all the way to the floor the right rear caliper would not hold. I think maybe the hose was partially restricted causing some flow but not enoug...	6
	2007 Mazda 3 S 2.3L No Start VIN: JM1BK143X7 SORRY I'M SO LATE CLOSING THIS REQUEST. I REPLACED THE CANISTER PURGE VALVE & THE OWNER CALLED & STATED THAT HE HAD NO PROBLEMS STARTING THE CAR THE NEXT TIME HE REFUELED. EVERYBODY HIT THE NAIL ON THE HEAD WITH THEIR RESPONSES. YA'LL MADE MY LIFE EASIER & I S...	9
	1999 Mercedes-Benz E320 3.2L starter VIN: WDBJF65H5X This car left today. Customer is going to trade it in. I did use a multi meter to test all of my power and ground signals. I used the test light to see if the circuit would still pulse with less of a load on it than the starter solenoid. I have seen circui...	13
	2003 Mercury Grand Marquis GS 4.6L No Start VIN: 2MEFM74W73 HI,EVERYONE. MY THANKS TO ALL OF YOU GUYS FOR YOUR HELP. LOOK LIKE COMPUTER REBUILDERS DIDN`T REPROGRAM THE ECM PROPERLY. WE FLASH THE COMPUTER THEN THE KEYS , NO MORE PROBLEM AND SHE IS OUT OF HERE. THANKS AGAIN MATT	9
	2004 Mini Cooper 1.6L Steering VIN: WMWRC33484 Well this ended up being a bad steering shaft(was binding bad). We ordered the OE pump unit, but didnt use it at this time. After doing the shaft, everything felt normal. Thanks everyone for the help - If the pump fails, I am going Oe for this.	8
	1990 Nissan D21 2.4L Fuel Gauge VIN: 1N6SD11S3L The customer returned to have the regulator installed and the part that nissan sent us was wrong. So the customer left and we go tthe right part in and he has yet to return for repairs. I will post if this has been fixed as soon as he returns and we install ...	4
	2002 Pontiac Sunfire SE 2.2L cluster, headlts & a/c VIN: 1G2JB124X2 Ckd everything and found that customer had removed grd cable at bat tray when he changed cables. I didn't see the hole where it went because of the corrosion. I ckd all the connections under tray, column frame and trans area. I put some scratch washers under t...	6
	1997 Saturn SC2 1.9L Mechanical VIN: 1G8ZG1273V Hey all thanks again for the replies and all the info, i think this will be helpfull to others who are having issues with these saturn engines which we all know have there problems. The primary concensus is these engines are great but need to be taken care of...	18
	2003 Saturn Vue 2.2L Pcm VIN: 5GZCZ23DX3 I would like to thank everyone for their help with this saturn. I did some more research and found the Body Control Module to be the fault. I learned that the BCM is the module that all the data has to pass thru to get to the DLC there for my loss of communica...	6
	2005 Subaru Legacy i 2.5L wheels VIN: 4S3BL61665 Thanks for all the help i ended up adding some limited slip additive and doing figure eights till i was sick the binding was gone i had the customer drive the vehicle for a few days to make sure the noise did not return and so far it has not. Thanks again for ...	11
	2001 Toyota Sequoia SR5 4.7L battery VIN: 5TDBT44A21 AFTER CHECKING THE TURN SIGNAL RELAY/FLASHER I FOUND NOTHING STICKING AND THE RELAY IS GOOD. I DECIDED TO REPLACE THE TURN SIGNAL SWITCH. AFTER REPLACING IT THE KEYLESS REMOTE SEEM TO LOCK AND UNLOCK THE VEHICLE NORMAL WITHOUT ANY LIGHT ON. THE VEHICLE WAS...	5
	2007 Toyota Yaris S 1.5L Fuel Pump VIN: JTDBT92357 Thanks everyone who trying to help, original pump and the second new one was burnt because guy who did the the job was to lazy to check amount of fuel in the tank - there was no fuel !!! The second used pump from junk yard fix the problem. There was a good gro...	7
	2006 Volkswagen Golf GLS TDI 1.9L MIL Lamp on, low powere VIN: 9BWGR61J26 Hi and thanks to all, one of you mentioned the adjustment for the waste gate rod. When we got the new turbo it had to be transferred over. On hills we would get overboost at [...]. There is no spec for this adjustment, so it took a while to get it right, ev... Trouble codes: 16791 (EGR curent low), 16627 (wategate solenoid), 17903 (Egr), 16618 (Turbo overboost).	5
	2001 Volvo S80 T6 2.8L Rpm Vss VIN: YV1TS90D61 Thanks for all the replies..This one turns out to be the input speed sensor in the trans..Reman co is sending another trans and will pay!!! Seems like the TCM stops recriving info when it goes into limp mode.. that would explain the info on the Launc freezing ...	5
	2002 Volvo V70 X/C 2.4L broken LF axle stuck in transmission VIN: YV1SZ58D32 We were able to get it out with a BIG slide hammer- center drilled the nub, tapped the hole out with a 3/8-16 tap, and pulled it out. no metal shavings get into the tranny- the nub is solid- just don't drill all the way through it. Got the tool o...	8

(Also Available: All, Asian, Chrysler, European, Ford, GM.)