Automotive Technicians Technical Discussion and Fixes for Apr 10, 2012

Join Now

Prev	Professional Automotive Repair Technical Discussions for April 10, 2012 International Automotive Technicians' Network (iATN) - Members Only	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for All Makes and Models

	Help Request	Answers
	2001 Audi A6 Quattro 2.8L Timing belt VIN: WAUEH64B81 I'm looking for some input on this job I will get next week. I will be installing a timing belt/pulleys, water pump and the camshaft chain tensioner seals. I've never done this before, but have read a couple of websites about it. The only special tools I have ...	View
	2004 Audi S4 Avant 4.2L Misfire VIN: WAUPL68E54 This car came in with intermittent misfires on cylinders 1, 2, 5, 7. It occasionally will act up for about 5 secs and it is only at start-up after sitting for a little while. The car exhibits no other issues when driving. Has anyone run into an issue like this... Trouble codes: P0300, P0302, P0301, P0305, P0307	View
	2004 Cadillac SRX 4.6L Surge, Stall, MIL Lamp on VIN: 1GYDE63A64 Hey guys, the vehicle first came in for a check engine light then the vehicle chuggs and eventually will stall, sometimes goes into reduced engine power mode. The vehicle had various codes for the throttle body which I found a tsb for which led me to change th... Trouble codes: P0013 (exhaust camshaft position actuator solenoid control circuit bank 1 passed), P2119, P0122, P0223, P2135, P2176	View
	1994 Chevrolet P30 7.4L Fluid VIN: 1GBKP37N8R Try putting fluid in resevoir n belches back as power steering begins to work.cut engine off n fluid comes back out thru lid,has hyro boost system for brakes n steering.pump is working cause as it runs low on fluid begins to growl.may pull a;; lines off n insp...	View
	1995 Chevrolet G30 Chevy Van 4.3L in limp mode VIN: 1GCFG35Z2S Customer stated the vehicle will not shift and stays in limp mode. The vehicle has codes,59 fluid temp high,67 torque convertor quad driver 2 solenoid,82 shift solenoid A, 81 shift solenoid B. I tested the power going into the transmission on the orange wire a...	View
	1995 Chevrolet Tahoe LS 5.7L Poor Idle Quality, Hesitation, Surge VIN: 1GNEK13K2S I recieved this vehicle it runs poorly idle surges has hesitation at lower rpms. If alternator is disconnected vehicle runs great and idles smooth. I have checked all grounds. charging system tests good. I have spent. Any help would be greatly appreciated	View
	1998 Chevrolet Corvette 5.7L no reverse,2nd,4th gears VIN: 1G1YY32G4W the car came in running fine. I did a complete paint job, repaired LH window motor, AC blower motor, idler pullys and belts, etc. When I was finished and ready to deliver the car, I got the dreaded "service steering lock" warning on the ICP. while fixing fix t...	View
	2000 Chevrolet Express 3500 LS 5.7L abs module VIN: 1GBJG31RXY no u codes set, light is on all the time pcm will set u1014 when ebcm is unplugged i can clear it and recheck no u code until ebcm is unplugged this box van was not equipped with air bag so there is one less module on the data line my question is i am trying t...	View
	2000 Chevrolet C3500 7.4L Poor Idle Quality, Misfire VIN: 1GBKC34J0Y Vehicle came in rough idle. No CEL on. Sold tune up (76k miles) due to good fuel pressure.still running rough. Checked Regulator snap throttle, pressure increase and i pulled vacuum on it and it held. installed new EGR valve bc the original did not respond to ...	View
	2007 Chevrolet Tahoe LTZ 5.3L MIL Lamp on VIN: 1GNFK13067 Got a real head banger here. This Tahoe came in with a blown engine. The push rods were all bent and the camshaft was broken. We installed a Goodwrench engine. After the install the speedo would read 20 MPH sitting still unless the shifter was in drive or low ... Trouble codes: P2135 (TPS Correlation), P0325 (Knock Sensor Circuit Bank 1), P0330 (Knock Sensor Circuit Bank 2)	View
	2000 Dodge Neon ES 2.0L Ignition/Sensors VIN: 1B3ES46C7Y I got this problem after customer had it at another shop. Custome states hard to start and check engine light on. Car runs ok after it gets started. She states that other shop says it needs a cam sensor. I scanned the car and get P0340 - No cam signal at PCM. ...	View
	2004 Dodge Ram 2500 ST 5.9L Unknown VIN: 3D7KA28C64 Customer just purchased this vehicle and we did a 150 point inspection on the truck. The truck has had basically no preventative maintenance at all. my concern is a noise that appears to be coming from the timing gear area, almost like worn gears and I am hear...	View
	2005 Dodge Dakota SLT 4.7L Transfer case motor VIN: 1D7HW48N25 The transfer range selector motor will engage while driving the car, the 4wd service light will come on intermittently, and the 4wd light flashes. Once the range motor made noise with the key out of the ignition, no one in the truck. Code C1404 and C1405 range...	View
	2008 Dodge Ram 3500 Laramie 6.7L Ecm/Tipm VIN: 3D7MX38A28 I am running into a dead end on this truck. The electronic throttle control light came on in the dash with no symptom while the customer was driving. He drove home and shut the truck off. It never started again. When you hold the key in the start position the...	View
	1997 Ford F-150 Lariat 5.4L 2-3 shift VIN: 1FTEX18L4V I've done everything I can think of before going online with this problem. I'm a smog tech with lots of experience but not on E4od Ford transmissions. Transmission was replaced for no upshifts after 1-2 shift.Clean used Ford reman was installed (I didn't do i...	View
	2002 Ford Taurus LX 3.0L Hesitation VIN: 1FAFP55U82 Hi Guys I have A taurus that came in claiming it ran rough and had no power. Confirmed it had no power and when you press the throttle it takes forever to accelerate and takes a good 5-10 seconds to even get up to 3500 rpm. I had checked Maf sensor, idle air c...	View
	2002 Ford Focus ZX5 2.0L Stall VIN: 3FAFP37382 Vehicle came in on a tow truck after customer stopped for gas and said vehicle would not restart. Upon starting daignosis, vehicle fired off and ran fine. Allowed vehicle to idle for more than 30 minutes, test drove vehicle, stopped and restarted vehicle sever...	View
	2003 Ford F-250 Super Duty XLT 6.0L Engine oil VIN: 1FTNX21P33 The problem with this is that I'm getting diesel fuel in the oil. I have changed all injector o-rings and brass gaskets (got all 8 kits fron dealer, one for each injector) on the injectors and changed the oil & filter 3800 miles ago and now is still over about...	View
	2004 Ford F-150 STX 4.6L Cuts out, Stall, sec lite flashes VIN: 1FTRF12WX4 Thank you in advance. I currently do not have truck in my posession, but am trying to help a friend. It will stall at stops (retarts fine), and while driving it will cut out and recover,(security lite flashes when this happens). There is no pattern to the symp...	View
	2004 Ford Crown Victoria Police Interceptor 4.6L Suspension VIN: 2FAFP71W34 This my own vehicle, thanks to all that reply. When driving 30mph or higher, if you accelerate the car pulls to the left, not bad, but noticable. once you let off, it drifts back to the right. almost like torque steer but the steering wheel dosen't move. check...	View
	2004 Ford F-250 Super Duty Harley-Davidson Edition 6.0L No Start, Stall, Misfire VIN: 1FTNW21P84 The truck o starts good cold, little longer crank time than normal but exceptable. now # 5 missfire is gone but it is showing missfire on #1 and still p2291 low icp pressure. suspect a stickin ipr that is causing the low icp pressures. have ordered new ipr but... Trouble codes: P2291, P0263	View
	2006 Ford Taurus SEL 3.0L Mechanical VIN: 1FAFP56U96 Ticking noise in engine that sounds similar to a rocker arm loose. All rockers were tight. Removed heads and had them refreshed. Found gouge in the top of the piston the shape of a piece of valve spring, buffed it smooth. The customer had a broken valve spring...	View
	2007 Ford Freestar SE 3.9L Cuts out, Stall VIN: 2FMZA51657 this vehicle stalls intermittenly at idle in park or drive. it just cuts out insatntly like a spark loss or injector shut off not like a fule loss. no codes and cant find any errounous sensor data. i removedthe computer as the bullitien states and didnt find a...	View
	2007 Ford F-150 XLT 5.4L Poor Idle Quality, MIL Lamp on VIN: 1FTPX14VX7 Hello. This Ford was traded in to our dealership. On a long test drive after it is hot, as the vehicle comes to a stop, it starts running rough and making a knocking sound from the timing chain area or from the valve cover areas. The codes that set all have to... Trouble codes: P0022 (Intake Cam Timing Over retarded bank 2), P0345 (Cam position sensor circuit malfunction bank 2), P0349, P0512 (Starter Request circuit)	View
	1998 GMC Jimmy Envoy 4.3L engine VIN: 1GKDT13W1W Hi, we have this little jimmy with what sounds like a collapsed lifter, a loud lifter type noise from passenger side of engine. Customer just had the intake gasket replaced for a extenal coolant leak about 800 k ago. we assumed it also was leaking internally a...	View
	2008 Honda Accord LX 2.4L cylinder head VIN: 1HGCP26338 Im doing a head gasket on the accord pzev. Is there anything I should be aware of .I noticed when you reassemble they talk of a LOST MOTION ASSEMBLY what is that? Im worried about this one so I cant begin to tell you how much I would appreciate any help I can ...	View
	2007 Infiniti G35 3.5L Hesitation VIN: JNKBV61E97 Vehicle has noticeable hesitation only on tip in from a dead stop, only when hot, MAF sensors replaced and no difference, air intake boots and all related hoses and clamps are in good condition and tight, no codes in system, coolant level was slightly low, top...	View
	1996 Jaguar XJ6 4.0L instrument cluster VIN: SAJHX1749T We have tesed battery and all connections. No voltage drop on either side + or -. Inspected all fuses related to instrument cluster in boot and under left rear heel cover and are good. removed instrument cluster and inspected for damaged connectors and inspect...	View
	2004 Land Rover Range Rover HSE 4.4L Bcm? VIN: SALMH11494 High steering effort during low speed maneuvers, dealer said BCM needs to be replaced. This car came to me from a new customer who got a $15,000 dollar estimate from dealer to fix various items on the car, one of the concerns was hard to steer in parking lots,...	View
	2006 Land Rover LR3 HSE 4.4L Parking Brake VIN: SALAG25456 HI Land Rover techs I need some advice. I have a LR3 here with a loud screeech noise and both park brake failure lights and warnings. Found RR brake rotor burnt right apart frome ebrake dragging. Once park brake activated the system faults and have to use the ...	View
	2001 Mazda Protege DX 1.6L Hesitation, Stall VIN: JM1BJ22211 Hi, this car has me in a pickle. slow acceleration ok until 3000 rpm, then bogs down. fast acceleration and same problem... Fuel pressure ok(has new pump), CMP, TPS, and CKT scopes patterns ok. Mass Air flow sensor ok (have swapped with good one- no change) Ha... Trouble codes: P0171 (Fuel Trim low), P1170 (Front HO2S - no inversion)	View
	2005 Mini Cooper S 1.6L Removal VIN: WMWRH33435 Thanks for the help on this. I am replacing the clutch on this Mini. I have never done a clutch on a Mini before, and Alldata says it takes 11.2 hours. Although it does not give any detailed description on how to remove it. My question is, what all is involved...	View
	1995 Nissan Maxima GLE 3.0L Timing Chain(s) VIN: JN1CA21D0S Customer complaint of noise upon start-up, particularly when cold. Noise can last up to a minute before it quiets down. He is pretty sure that is coming from timing chain area. Of course, now that the car is here, at the shop, it won't act up. I know these eng...	View
	2006 Saab 9-3 2.0T 2.0L Programming VIN: YS3FD49Y16 Thank you in advance for your help. Customer and another shop have been working on this car looking for a engine shutting off/on problem. The 2 main problems at this point are: 1.They replaced the CIM for some reason, but it shows that it is not added, althou...	View
	2001 Saturn LW300 3.0L Mechanical VIN: 1G8JW82R01 Help! This car goes full rich and i cannot seem to find it. fuel trims are reading -30 both banks with o2 sensors upstream stuck between .970-.950 and downstream reading 450 mv.I have checked timing belt for jumped tooth,fuel pressure,vacuum tested,and backpre...	View
	2001 Saturn L300 3.0L No Start, Hesitation, Stall VIN: 1G8JW52R41 thanks in advance for all that help car will start and run good 1st time in morning but has a hesitation shut car off and wont restart for about 5 or 6 tries then will start up run rough then clear up we put a new throttle body on it and maf sensor did the rel...	View
	1997 Subaru Legacy Outback 2.5L MIL Lamp on VIN: 4S3BG6858V This Subaru has been giving us the run-around for about six months now. It keeps throwing misfire codes for cylinders three and four no matter what we do. It doesn't run particularly rough or smoke, and it doesn't feel like a dead miss. We've pulled down the e... Trouble codes: P0303, P0304	View
	1999 Subaru Legacy Limited 30th Anniversary 2.5L starting VIN: 4S3BG6855X No communication to the DLC and no start condition. There is no spark or fuel injector pulse. If you disconnect the battery and reconnect it you will have power to the DLC but as soon as you turn the key on you loose power to the DLC and the cooling fan turns ...	View
	1998 Toyota Sienna CE 3.0L water pump VIN: 4T3ZF19C2W Good morning. Has anyone had water pump issues with this vehicle? I have installed a new thermostat however, have no flow. Radiator is cold, no heat from vents but engine is hot. Just alot of work to axcess w/p but thats where i,m headed. Your response is grea...	View
	2004 Volkswagen Passat GLS 2.0L MIL Lamp on VIN: WVWVE63B84 Hi got a vw that is driving me nuts it originally came in blowing black smoke no power and check engine light on with underboost code and air flow meter code. Checked turbo and when hot it would hardly turn by hand and it was leaking oil so replaced the turbo ... Trouble codes: P0299	View
	2006 Volkswagen Jetta TDI 1.9L No Start VIN: 3VWNT81K26 hi my mechanic replace the clutch on this vw tdi and it wont start if I disconnect the cam sensor it would try to start when cranking only . we hardly work on disel .do not known where to start.car run good before we replace the clutch.thanks	View
	1997 Volvo 850 GLT 2.4L Air injection relay VIN: YV1LS5647V What can i do to make sure this does not happen again. Has anyone relocated this relay to a dryer place.The belly pans just cant keep the water out. Any suggestions? Thanks, Jim (Seattle)	View
	2004 Volvo XC70 2.5L camshafts VIN: YV1SZ59H84 Hello, I working on this vehicle and resealing camshafts and crank and valve cover due to crankcase pressure leakage(pcv) system failure, I did not realize that these sprockets and cams have no line up markings as well as top dead center. Before I removed belt...	View

Fixes & Summaries for All Makes and Models

	Fix/Summary	Answers
	1988 BMW 325i 2.5L Poor Idle Quality, Hesitation, Cuts out VIN: WBABB2304J Fixed it after It kicked my butt! Found Injector 2 had 2 ohms. The rest had about 15 Ohms. It was shorting out the driver from the ecm when you would rev it up. Wierd thing is the main relay would never falter only the signal to the o2 relay and fuel pump ...	3
	2001 BMW 325i 2.5L MIL Lamp on VIN: WBAAW33431 thank you for all the help. we suspect sticky lifters like some of your posts. customer declined repairs at this time Trouble codes: P0305.	14
	2002 Cadillac Seville STS 4.6L Ride Control VIN: 1G6KY54992 Thanks to everyone for the suggestions. First; we did do quite a bit of research prior to replacing the electronic suspension. No one actually lists a replacement kit for a MagnaRide suspension. I spoke to Arnott Inc. and they verified that they could not supp...	7
	1984 Chevrolet Corvette 5.7L Poor Idle Quality VIN: 1G1AY0785E Thanks to all who replied, especially to Jeff from Washington, used the Chrysler fuel filter with the return, works very good. Used a stock 4 bl intake and a Holley 600 CFM.	16
	1989 Chevrolet Corvette 5.7L speedo tach VIN: 1G1YY2186K I`M DOING WHAT MY ATN MEMBERS HAVE INFORMED ME WITH N SPEEDO IS ON WAY TO SPEEDO SHOP.ITS MY SONS CAR N WILL HAVE TO WAIT N LINE TILL I HEAR FROM REPAIR SHOP..THANKS TO ALL	10
	2007 Chevrolet Suburban 2500 LT 6.0L abs VIN: 3GNGK26K27 Has been a tough one and did not get any helpful replies. When monitoring VSS when ABS light would come on the signal was good and steady. This would usually happen with rapid turns. When monitoring the signal at the EBCM from the PCM when the problem happened...	4
	2000 Dodge Ram 2500 5.9L No Start, Stall VIN: 1B7KF236XY Its fixed. But it's a strange story. Dropped the fuel tank in order to inspect the fuel components and replace the kinked fuel line and noted lines were damp with fuel near module connections. Pulled out pick-up assembly and to my surprise it held an electr... Trouble codes: P0336, P0720, P1689 (No comm between ECM and Inj. Pump), P0230.	23
	2001 Dodge Grand Caravan Sport 3.3L Hesitation, Cuts out, Misfire VIN: 2B8GP44341 CUSTOMER NEEDED VEHICLE AND HAS NOT BROUGHT IT BACK. I CHECKED FLYWHEEL WITH MY NBOROSCOPE AS GOOD AS I COULD WITH NO PROBLEMS FOUND. TPS WAS SCOPED WITH NO DROP-OUTS OR GLITCHES FOUND. THANKS AGAIN FOR ALL YOUR HELP.	10
	2002 Dodge Dakota SLT 4.7L timing chain VIN: 1B7GG42N22 thank you for all the help. this one can be called fixed!!! what i found was both cam chains where streached and the guides worn a bit. mostly the tentioner guides. this excessive wear caused the tentioners to be fully extended so they could not keep tention. ...	6
	2005 Dodge Neon SE 2.0L Poor Idle Quality, Hesitation, Cuts out, Stall, Misfire, MIL Lamp on VIN: 1B3E526C75 was a bad ecm, vehicle was so overloaded that it took out ignition coil, fuel pump, cooling fan, and ecm. thanks for the great feedback from everyone, it's kinda cool that you actually have someone willing to help others without their hand stuck out saying pay...	7
	2006 Dodge Stratus SXT 2.4L Hesitation VIN: 1B3EL46X46 Thanks to all that replay, spetially to David from Ohio. This car really has a lot of cankshaf end play. Specs are 0.09-0.24 mm wear limit 0.38 the readings are 2-2.5mm ! Unfortunately, I could not find information about how this play afect the crank signal. T... Trouble codes: P0016 (crank/cam time misalignment/out of syncronization).	9
	1999 Ford F-250 Super Duty Lariat 5.4L cylinder head VIN: 1FTNW21L9X Thanks to all who respondet. I took all answers to consideration and bought the time sert kit with aluminium inserts like ford and most of the guy's recomendet. it was pretty strait forward,a little expensive but works great, and I dont have to worry about it....	19
	2004 Ford F-350 Super Duty King Ranch 6.0L fuel VIN: 1FTSW31P14 Thanks to all who weighed in on this problem. As it turns out, my fuel pressure test equipment was giving me false readings. So after I verified correct fuel pressure I pulled th glow plugs found #1 cylinder to be badly over fueling. In the end I determined th...	8
	2006 Ford F-350 Super Duty XL 6.0L fuel system VIN: 1FDWX36P36 Like all of you suggested, I found the orings on dummy plugs badly damage.Ive replace them and the truck will start know after it gets hot with the exception that it needs and extended crank before it starts, I believe its another leak near the hpop.the owner ...	18
	2007 Ford F-150 XLT 4.6L Coolant in spark plug hole VIN: 1FTRW12W57 Thank you iATN techs! We pressure tested the cooling system to no avail on this one, but just like a lot of you said, the intake had started to come apart on the opening near the thermostat. No way to get it to leak with pressure test, it did seep a little bit...	20
	1998 Jeep Grand Cherokee Laredo 5.2L quadtrac VIN: 1J4GZ48Y6W 23 Members help is fantastic thanks everyone. I was very thorough in checking basics with this jeep -rear end, uni joints and tires. I did have a spicific question here- "could it be the front diff" The question was answered NO it cannot. Only after my update...	24
	2003 Mazda 6 i 2.3L Poor Idle Quality, Surge, MIL Lamp on VIN: 1YVFP80C33 Thank you all so much for your time and the replies. The customer didnt want to go any further with the vehicle. He said he will bring it back when he has more money or it gets worse. I will update if he brings it back. Thanks again. I do believe it is timing ... Trouble codes: P0300.	16
	2008 Mazda CX-7 Touring 2.3L Horn VIN: JM3ER293X8 Well unfortunately I have not fixed the Mazda horn. The customer brought the car back and I rechecked things. This time I found the horn worked perfect all the time with the key off. As soon as you turn the key on with the steering wheel in the straight ahead ...	8
	2002 Mercedes-Benz E320 4Matic 3.2L Unknown VIN: WDBJH82J92 Wrapped up this head ache once and for all. It ended up having an internal failure. Thank you for all of your replies. A special thanks to Wayne from Russel Auto. Wayne helped me see the woods through the trees. When the tranny would fail the pump would whine....	26
	2003 Mini Cooper S 1.6L Battery isolation device VIN: WMWRE33483 The airbag trigger wire (SBK)connection had corroded under the black plastic cover on battery positive terminal, hence the 'high resistance.' In fact, one of the pins in the connection was non existent. Too bad BMW/Mini doesn't make a terminal repair kit so t...	6
	1999 Mitsubishi Montero Sport LS 3.0L cooling system VIN: JA4LS31H6X Thank you for all of your suggestions. I did replace the thermostat and the problem seems to be gone. I also pulled a vacuum on the system before filling it with antifreeze. No problems for now and hopefully it stays fixed. Thanks again to everyone.	11
	2000 Nissan Maxima GLE 3.0L No Start VIN: JN1CA31D8Y Thanks to all who replied. Thanks Ken [...] for your help. And you nailed it. I was losing ground between the trans and the block. We pulled the trans and sanded both surfaces. Put it back together and it started. Thanks again to all, IATN rules. Trouble codes: P0325.	12
	2005 Nissan Altima S 2.5L timing chain VIN: 1N4AL11DX5 Thanks for the replys. What we ended up doing was bringing the engine up to top dead center, removed the camshaft gears and lined the camshafts up on top dead center. We had a good picture of how these we supposed to be oriented with the gears off. While looki...	5
	2001 Saturn SL 1.9L Poor Idle Quality, Stall, Poor Fuel Economy VIN: 1G8ZF52871 Thanks for the replies. I ended up changing the O2 sensor and the temp sensor and the vehicle seem to run a whole lot better. The scanner showed better O2 switching and the temp seemed good. Still not sure what was going on with the dash issue because it didn'... Trouble codes: P0133 (O2 lazy), P1133 (no O2 switching), P1599 (eng stall), P1626 (pcm to bcm loss comm), U1064 (lost bcm comm), U1301 (class 2 data link high).	8
	2007 Saturn Aura XR 3.6L all lights VIN: 1G8ZV57787 The car ended up having a bad alternator. When I would unplug it the flickering went away. thanks to everyone that repiled to my request. The car is working and the customer is happy.	6
	2005 Subaru Impreza WRX STI 2.5L MIL Lamp on VIN: JF1GD70695 Well after graphing the sync between the cam and crank sensors and verifying oil pressure hot and cold we decided to try a different ECM, got a used ECM with most recent part number and had the dealer program it for the key and the problem is fixed. Many thank... Trouble codes: P0011 (Camshaft Position A Timing Over Advance Bank 1), P0021 (Intake Camshaft Position Timing - Over Advanced Bank 2).	3
	1995 Toyota Camry LE 2.2L No Start Well it looks like it was almost unanimous! I pulled the timing cover and the camshaft seal had been leaking oil for so long, the timing belt became soft and kinda stretched, so it's no wonder that it jumped time. I talked with my customer and we decided to in...	34
	1998 Toyota Tacoma DLX 2.4L MIL Lamp on VIN: 4TANL42N8W The fix was to replace the egr vacuum modulator valve. The test for the valve is to remove it and see if one can blow through the port on the bottom of the valve that exhaust flows through. If you can blow through it than it has failed. Some of the replies als... Trouble codes: P0401 (Insufficient EGR Flow).	13
	1998 Volkswagen Jetta GLX 2.8L Clutch VIN: 3VWTD81HXW Customer has not been back or called since the vehicle was released. We can only assume it's fixed or she's taken it somewhere else. Thanks to all for taking the time to respond.	21
	2002 Volkswagen Jetta GLS 2.0L Pedal VIN: 3VWSK69M12 Thanks for all the replies, mostly mentionaing not to miss the posibility of a stuck caliper pin. After checking the brakes thoroughly, I did a master cyclinder. The pedal was about the same after doing so. It was until going into 02 Engine, group 008, basic s...	15
	2002 Volkswagen Jetta GLS 1.8L MIL Lamp on VIN: 3VWSE69M52 Thanks for all the replies. I rechecked all the marks one last time and all of them were on the money. I pulled off the cam sensor and its tone wheel to have a good look at the end of the cam. when I installed the wheel the tab that fits into the cam was a bit... Trouble codes: P1340 (Cam sensor Incorrect Correlation).	9
	2005 Volkswagen Jetta 2.5 2.5L Tranmission VIN: 3VWRG71K75 Thanks again to all those who replied. All good info as usual. This one finally kicked out a code P0571 Brake pedal switch malfunction. It took a lot of test drives and 3 scan tools, snap on, Vedis and Ross tech. Finally after one of the failures it set the P0...	10
	2001 Volvo S80 2.9 2.9L Hesitation VIN: YV1TS94D01 thanks for the help. i pulled pump back out & found the left side of saddle tank was low on fuel. i didnt give it enough time to equal out.	2
	2005 Volvo S40 i 2.4L No Start VIN: YV1MS38215 THANKS FOR ALL THE REPLIES,THE INFORMATION ON CRANK SENSOR FIRING COILS HELPFUL,WE WERE ABLE TO TRACE A BROKEN WIRE TO CRANK SENSOR,REPAIR WIRING ,CLEAR CODES,START CAR AND ROAD TESTED, ALLS WELL THANKS AGAIN Trouble codes: 3200 (Ignition coil), 3300 (Ignition coil 1), 3310 (Ignition coil 2), 3320 (Ignition coil 3), 3330 (Ignition coil 4), 3340 (Ignition coil 5).	4
	2006 Volvo S80 2.5T 2.5L 1-2-3 upshift,3-2-1 downshift VIN: YV1TS59226 Transmission shopped replaced the transmission and all seems well, thanks for all the input from everyone.	6

(Also Available: All, Asian, Chrysler, European, Ford, GM.)