iATN Member Chrysler Auto Repair Tech Exchange for June 4, 2009

Overview | » TechHelp | Web Forums | Technical Resources | Live Conferencing | How to Join

Prev	iATN Members TechHelp for June 4, 2009 Automotive Technical Exchange for the Automotive Repair Professional	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for Chrysler

	Help Request	Answers
	2001 Chrysler Voyager 3.3L engine I am VW and Chevy man. This poor girl ( which i have known for 25 years)Bought this Mopar minivan with out me checking it first...Well we have low compression on #3 and #4 less then 50 lbs. The others are not great eather.Its the 2 center cyl. on each head.Of ...	View
	2003 Chrysler Town & Country 3.8L No Start, Stall Thanks for help on this car.This car with no codes stored starts and runs ok when cold then after about 5-10 minutes will stall and wont crank when you try to restart.Prior to arriving here an ignition switch was installed but made no difference.Thanks for eve...	View
	1998 Dodge Intrepid 3.2L Fan operation The car over heats. I found that the cooling fans will not come on. THe PCM grounds the relays to turn them on hi or low. PCM shows correct coolant temp. If I turn the ac on they work normal. The compressor is seized and there is no belt. Any ideas why they on...	View
	1999 Dodge Grand Caravan 3.3L rear axle assy. customer complaining of noise from rear axle,has had this vehicle for about a year.stated that noise has only gotten slightly worse.we've only seen a couple of these all wheel drive units in the shop.the rear axle is a cv joint unit aluminum case.my question i...	View
	2001 Dodge Grand Caravan 3.3L Spark Good morning IATN members. I have two issues on the same van, first off, this van drove into the shop with the system of when he turned his A/C on and the A/C clutch engaged the car would stall right away. So I did some poking around and noticed that the radia...	View
	2002 Dodge Durango 4.7L Door Locks The Horn will sound off intermitently until it stays steady. When the horn chirps the rear wiper moves just a little, but when the horn stays on the rear wiper stays on with the horn. door locks will lock intermitently but not every time the horn sounds. Very ...	View
	2002 Dodge Durango 4.7L Accumulator Not much data I know but here is what happened. Customer complained of a noise in the AC at idle. I duplicated it once but didn't get a chance to get pressures before it stopped. The accumulator/Drier was vibrating and causing a "moaning" noise. Disconnect com...	View
	2004 Dodge Pickup 5.7L trailer plug Rig came in for trailer plug having no turn signals or brAKE lights. we looked in Mitchell and there are supposed to be two relays for running turn sigs to the trailer plugs, but we cannot find them. Both Mitchel and Alldata say they are in the power center un...	View
	2007 Dodge Pickup 5.9L unknown Have this truck with 315 70 17 tires 2inch leveling kit with extened length shocks and new steering stabilizer that intermitantly or randomly will shake VIOLENTLY after hitting a uneven joint at a bridge when going 60mph and higher. The first time it did this ...	View
	2000 Jeep Grand Cherokee 4.0L engine Thanks in advance - concern is No Start - Confirmed customer concern of cranks but won't start - tried and was unable to communicate from scanner to vehicle PCM - unplugged all 5v referance sensors and was then able to communicate - plugged sensors back in one...	View

Fixes & Summaries for Chrysler

	Fix/Summary	Answers
	1999 Dodge Pickup 5.9L Cuts out well, i cleared the p1694, and it never came back. but the cut out problem, thanks to the input i did get, made me take a harder look at the engine harness wiring, particularly the tps module harness on the diesel injection pump. i found an old aftermarket po... Trouble codes: P1694 (no bus message recieved from companion diesel module).	5
	2001 Dodge Pickup 5.2L interior lighting Hi everbody. Sorry it took so long to close this post. I am not convinced the problem is fixed yet. We have been waiting for some heavy rain because that is when it seems to act up. We have tested all the wiring from the right door switch to CTM are what ever ...	6
	2003 Dodge Ram Van 5.2L Stall We received three replies. One, the crank sensor, we had already changed by the time the reply arrived. The third reply, checking the orange wire, we did and it passed the test. We were leaning toward the PCM, but the car owner had just bought the car 2 month...	3
	2003 Dodge Sprinter 2.7L long crank time Thanks for the responses, most suggested cranking the motor over to use compression to help push it out, but this was stuck way to tight for that! We ended up welding a nut to the top of the injector and working it back and forth patiently until we could pull ...	4
	2004 Dodge Pickup 5.7L Hesitation, Misfire, MIL Lamp on Thanks again to you all for helping me out! As most of you mentioned it turned out to be the upstream O2 Sensor. I swapped them from side to side and the code moved to the other side. I replaced it and all is well! Trouble codes: PO300 (multiple cylinder misfire), PO152 (o2s voltage high bank 2 sensor 1).	6
	1987 Jeep Cherokee 4.0L engine at this point we decided to remove the timing cover and inspect, since a problem in this area could have been causing the original complaint,so we removed it and there was no problem found, we loosend up the remaing rod/main bearing, still no turn,so we are re...	21
	2000 Jeep Cherokee 4.0L No Start, No Bus. Blown Fuses Thank you everyone for your help. Gary hit the nail on the head! Rear O2 harness was rubbing on the driveshaft and was shorted. Patched harness and all is well! Thanks again for all the help and advice recieved.	6
	2004 Jeep Grand Cherokee 4.0L MIL Lamp on As stated above the vehicle is fixed. I traced the wires around and at the back of the head (facing the vehicle from front bumper) on the right side the harness rubs the very last head bolt which has a stud protruding. The Brown/White wire which is one of th... Trouble codes: p0051 (Oxygen Sensor Rear Bank Sensor 1 21 Heater Circuit Problem).	None
	2005 Jeep Grand Cherokee 3.7L check eng light I received 3 replies. One said to check grounds. Another told me about a tsb(#08-046-05) for communication problems. Jay said he had replaced several shifter modules(actual shifter bezel) for code U0404. The next morning, I removed the shifter trim. Found drin...	3

(Also Available: All, Asian, Chrysler, European, Ford, GM.)

Copyright ©1995-2009 iATN. All rights reserved. Terms of Use | Privacy Policy