Chrysler Automotive Technicians Technical Discussion and Fixes for Aug 17, 2007 - iATN (Members Only)

×

Join Now

Prev	Professional Automotive Repair Technical Discussions for August 17, 2007 International Automotive Technicians' Network (iATN) - Members Only	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for Chrysler

	Help Request	Answers
	2004 Chrysler 300M 3.5L miss? on hills VIN: 2C3HE66G64 Good morning . I am a suspension tech and only know enough about the new electronics to be dangerous.[old fart,plugs and points era] This is my own car.It is a delight to drive and has lots of pep on the open road. On a hard pull on hills it does not have the ...	View
	1999 Dodge Grand Caravan LE 3.3L steering wheel VIN: 1B4GP54L2X Guys, This time I have an amusing problem for y'all. This vehicle has been to us before with this condition but only now are now looking into it. The steering wheel has a low speed wobble that makes the wheel shake in your hands but not violently. We have see...	View
	2000 Dodge Durango R/T 5.9L abs VIN: 1B4HS28ZXY thanks in advance . this vehicles brake petal pulsates at slow speeds like the abs is being applied[ 10 km or less & only intermitantly that it occurs ]we have changed the left front wheel bearing to erase the code , as the speed sensor was not reading correct...	View
	2000 Dodge Grand Caravan 3.8L Unknown VIN: 3V4REUYDNY Greetings to all Mopar men... I need a little help on this van as I dont do many domestics. Lets see- a 2000 caravan with a 3.8 and no rear air. Has a leaking evap, no big deal- we fix that and charge up the car and everything is perfect... Until the next day ...	View
	2001 Dodge Dakota Sport 4.7L engine performance VIN: 1B7GG2AN51 looking for a dodge tech or someone that has ran into this problem before. the truck came in as rough running and check engine light on. engine has a misfire and the only trouble code found is cyl. #4 misfire. the coil is firing and injector is working properl...	View
	2002 Dodge Durango SLT 4.7L Excessive Emissions, No Start, Stall, MIL Lamp on VIN: 1B4HS48N42 Net Techs, Need some help here. This Durango was towed in because it was repeatedly dying on the owner. Moved it into the shop at the end of the day and could tell it was massively overfueling. Raw gas literally pouring out exhaust. Went to diagnose this morn... Trouble codes: P0320 (ckp circuit), P0725 (engine speed sensor circuit)	View
	2005 Dodge Grand Caravan SE 3.3L Cooling Fans VIN: 1D4GP24R25 This is a dual AC system. The complaint is intermittent loss of AC. When the high side gets to about 300 psi, the high-pressure switch shuts the system down. The cooling fans are continuously variable. As the AC, pressure raises and or the engine temperature g...	View
	2006 Dodge Grand Caravan SXT 3.8L blower resistor VIN: 2D4GP44L96 We have had this van in 3 times and have changed the blower motor resistor. Have followed the in house memo from Dodge. Resistors only seem to last about a week. we can jump the deiod and blower motor will work. If anyone has any suggestions please let us know...	View
	1999 Jeep Grand Cherokee Limited 4.0L transfer case Hello all. I have this jeep here that came in for a hard clunk when shifting into reverse. I did all the basic checks such as u-joint and diff.Diff was pretty much junk so we had it rebuilt by a friend of mine but the clunk is still present.After some research...	View
	2000 Jeep Cherokee Sport 4.0L Steering VIN: 1J4FF48S2Y Hi everyone this jeep is killing me I have a shimmy/wobble @ 50 mph the tires are fairly new . I have rebalanced them and also put different wheels and tires on but still there. The front end is tight. The track bar had a little play so I replaced it but no lu...	View
	1995 Plymouth Voyager 3.0L pcm VIN: 2P4GH2537S this repo has been on my lot for over a year, it is a very nice looking and was a nice running van untill the last folks that"rented" it. they ran a hot wire for some accessory maybe a car stereo amp i am not sure. i am wondering about that , any ways it is ne...	View

Fixes & Summaries for Chrysler

	Fix/Summary	Answers
	2001 Chrysler PT Cruiser 2.4L defective head gasket VIN: 3C8FY4BB71 Thanks very much for everybody's help on this Crysler.I raised the engine about 4 inches and that was enough to get the long motor mount bolts out and remove it.Then came the sprockets and cover and then the head.I then checked for warpage and found it was .00...	9
	2004 Chrysler Sebring LX 2.4L air pump VIN: 1C3EL46J24 Found Relay replaced and solved problem Thanks GUYS for the Help	5
	2004 Chrysler PT Cruiser Limited 2.4L no crank VIN: 3C8EY68B94 Sorry for the delay in closing post. Some of your replies were very helpfull. One listd all the power and grounds necessary for the PCM to power up properly, great info!And yes the ASD relay was energized. Two gave a link to a fix in the data base. All good he...	5
	1995 Dodge Dakota 3.9L Excessive Emissions VIN: 1B7GL23X55 Thanks for the feedback on this one everyone. We replaced the cat and the nox came down to around 250 ppm on the smog test. The thing that was misleading to us was the diag on the cat was done by drilling before and after the cat.The diag test was done under...	4
	1998 Dodge Intrepid ES 3.2L compressor VIN: 2B3HD56J5W We got this Intrepid fixed, thanks to Jeff, Keith, Craig and David, you guys nailed it. We replaced the sensor and pigtail and the AC works great, IATN has been a great tool for my shop and I really appreciate all of your help.	7
	2001 Dodge Durango 5.9L exterior light VIN: N61F528694 replaced timer module (bcm) and that fixed it. thank you to the people that replyed you are the best.	6
	2001 Dodge Neon ES 2.0L Surge, MIL Lamp on VIN: 1B3ES46C41 First off I'd like to send out my thanks to all who took time to respond. This repair was one of those we techs would just a soon not run into. The fix was to replace the up stream o2 once again with another OEM. Including the original o2 this was the third OE...	5
	2002 Dodge Durango SLT 5.9L air out of vents VIN: 1B4HR48Z72 seems like i have a blend door seal that has gone bad, bypassed the heater core and a/c is blowing 42 degrees out of the vents, waiting on the customer to come up with the money to have the blend doors replaced. thank you for your help.	5
	2005 Dodge Grand Caravan SXT 3.8L left power sliding door VIN: 2D4GP44L45 thanks for the help on this one guys. i got alot of replies, most of which said to look at the wiring inside the flexible plastic chain track at the bottom of the door. i found a black wire that was broken at 2 places inside the insulation, which was still int...	15
	2000 Jeep Grand Cherokee Laredo 4.7L cooling system VIN: 1J4GW48NXY You guys hit the nail on the head IATN rocks. The radiator fixed the over heating, Thanks a million	13

(Also Available: All, Asian, Chrysler, European, Ford, GM.)