Automotive Technicians Technical Discussion and Fixes for Jul 28, 2011

Join Now

Prev	Professional Automotive Repair Technical Discussions for July 28, 2011 International Automotive Technicians' Network (iATN) - Members Only	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for All Makes and Models

	Help Request	Answers
	1996 Acura RL 3.5L Stall VIN: JH4KA9656T hi all this car is from car lot. this car was towed in startes and dies 10 sec later will start right back up then 10 sec.will die this well go on forever. tested fuel pressuer has good fuel tried adding carb ceaner on help it like you turn the key off.	View
	2000 Audi TT 1.8L Stuck LTFT numbers VIN: TRUTC28N2Y The customer needs a new catalytic converter, but we don't want to put on a new cat if the engine has really strange Long Term Fuel Trim numbers. At first it was stuck at 16.8% and never moved no matter what. We could create a massive vacuum leak, remove the m...	View
	2000 BMW 323i 2.5L Oil warning light VIN: WBAAM3344Y The customer is complaining that the oil warning light is coming on while driving. After futher inspection we noticed that with the key on, engine off, the light is red and come on and off like its supposed to. After 15-30 seconds however, the light will come ...	View
	2001 BMW 330i 3.0L 4-5 shift fail safe VIN: WBAAV53401 read above info put in wrong section	View
	2003 BMW X5 3.0i 3.0L Charging VIN: 5UXFA53523 Hey, Boss is away and we cannot get this BMW X5 to charge. The charging voltage is approx. 12.33v while driving/cruising. If we turn all loads on voltage drops to 11.2v. Replaced alternator 2 times with NAPA brand #213-9581, no change in charging rate. Battery...	View
	2004 Buick Rendezvous CX 3.4L Blower Motor VIN: 3G5DBO3E04 customer came in with a2004 buick rendeevous with manual a.c. the blower motor ran all the time even with the ign switch off,i replaced the blower resistor still ran,replaced blower motor still ran, picked up a hvac mod. through a salvage still ran, i can unpl...	View
	1989 Cadillac DeVille 4.5L Blower VIN: 1G6CD515OK Thanks for help in advance. This car is haunting me. Blower is inop. I have no power on ckt 761, the orange wire from the bcm to fusible link and on to the power module and the blower motor. I have tryed a used bcm and have the same results. I do have 6 volts ...	View
	1990 Cadillac DeVille 4.5L Hesitation, Cuts out, Stall Hello Ace techs, thanks for taking the time to view this post. I'm working on a 90 Cadillac Deville 4.5 pfi. At times the engine will lose all or nearly all throttle response as if all cylinders are dropping out, yet the engine stays running at idle. This can ...	View
	1988 Chevrolet Camaro 5.0L runs away VIN: 1243FGTR6W vehicle idles fine until put in gear. then goes to 1500 and you half to hold on brakes to get it to stay and it is dificult to get stoped.	View
	1988 Chevrolet Corvette 5.7L Excessive Emissions VIN: 1G1YY218XJ Thanks in advance. Exhaust readings are loded mode. After replacing egr nox went up. Before replacement 807 15mph and 479 25mph. Cleaned all ports for egr and no restriction found. Egr port is not getting as hot as we would expect. Front cats seem to be workin...	View
	1999 Chevrolet Malibu 3.1L ac system VIN: 1G1ND52J1X Customer brought car in for no a/c. I checked pressures and looked for leaks none found, pressures were just a bit off @ hi150 lo 25. so i recharged and pressures were at 200/30 but still only cooling about 10deg F from ambient. compressor runs continuously. I...	View
	2003 Chevrolet Silverado 2500 HD LT 6.6L Excessive Emissions, Poor Idle Quality VIN: 1GCHK23173 hello fellow techs, im gonna start with numbers im hoping to get something figured out on this pick up. p0380 was present when we got the truck not too worry about it at this time, p1238 was said to have showed up at other shop but wasnt preset when we got it... Trouble codes: P0380, P1238	View
	2008 Chevrolet HHR LS 2.2L shifter VIN: 3GNCA13D38 The car somtimes will not shift from park. when it will not shift I have my brake signal from the peddle sensor to the bcm. but the bcm does not put the voltage out to the shift lock solenoid. My conclusion is the transmission range switch but i could not find...	View
	2004 Chrysler Pacifica 3.5L P0755 2-4 solenoid VIN: 2C8GM68494 Hi there everyone and thanks for the help. I have this Pacifica that has me pondering a new line of work. The car came in and appears to be in default mode, like 2nd gear starts and the light is on with a code P0755, 2-4 solenoid circuit. I do not have any tra...	View
	1994 Dodge B350 5.2L No Start, Poor Idle Quality VIN: 2B6JB31YXR I have this beauty of a camper here all the parts that were replaced was elsewhere.The issue is starts fine cold and will run fine for about 20 minutes then when at an idle it will flucuate if raised slightly off an idle in park it seems there is a slight miss...	View
	2002 Dodge Grand Caravan Sport 3.3L blend door VIN: 1B4SSP4436 This van has cool air on passenger side 69 degrees, warm air on drivers side, 90 degrees. Outside temp here is 97 degrees. The rear air does not cool at all. this vehicle came from another shop. We first vac and recharged the system, it had been overcharged, p...	View
	2003 Dodge Ram 2500 5.9L Throttle response VIN: 3D7KU26C43 Im getting a headache ,Problem child dodge ram pickup.Low power and improper throttle response.This is a little different than i suspect,Throttle does raise RPM but is not controlled,When you just touch trottle it will raise but you can not limit it .It will s... Trouble codes: P0642 (Fan speed), P0483	View
	2006 Dodge Sprinter 2500 2.7L MIL Lamp on VIN: WD0PD64406 This vehicle will set this code after driving on highway till engine is at running temp, Decel like getting off exit ramp & accel hard to merge & then the engine light comes on and Code P2047 sets. All fuel pressure readings are normal.Test fuel injectors. Rev... Trouble codes: P2047 (Fuel rail pressure at max)	View
	2007 Dodge Caliber SE 2.0L filter VIN: 1B3HB28B37 we are replaceing a cvt transmission in a caliber. Does anyone know what filter goes in the cooler housing? The dealer is telling us that it is not serviceable, does anyone have a solution?	View
	2009 Dodge Caliber SXT 2.0L blower motor VIN: 1B3HB48A09 i have a 2009 dodge caliber with no blower motor and no seat heaters for the driver or passenger seats i can suply bat volts on the blue/pink wire and the fan runs and the selector switch will control fan speeds i see there is a fuse box under hood and all fus...	View
	1981 Ford F-150 Custom 5.0L No Start VIN: 1FTCF10F0B Ok mabey someone can point me in the right direction on this. This truck came in a couple of weeks ago with a no start. It was not getting any fuel out of the fuel pump. I replaced the pump and still no fuel pressure. I checked the lobe on the end of the camsh...	View
	1988 Ford Ranger S 2.3L Excessive Emissions VIN: 1FTBR10A1J hello, I have this 88 ford ranger that runs rich all the time. I have found the problem but unable to solve it. there are no codes but the baro reading is 308mhz koeo and 215mhz when koer. I am under 1000 feet sea level so it should be 156mhz. I have check ref...	View
	2003 Ford F-250 Super Duty XLT 6.0L MAFq VIN: 1FTNW24ED3 truck came in with MIL on. (P0102) No power and high boost. PID readings: 0 MAF and 0 MAF volts. we tryed new turbo, PCM, MAF sensor and have gotten no where. any suggestions please help... we also checked harness and did the pinpoint test.	View
	2008 Ford Escape Hybrid 2.3L Cuts out VIN: 1FMCU49H68 Have this '08 Hybrid,came in not staying running for more than a few seconds, replaced high voltager battery now will start and stay running but will randomly cut out with "stop safely now" message appearing, this can happen right at cold start up or just sitt... Trouble codes: P1A0C, U2023 (Fault recieved from external node), P0106 (Map circuit fault)	View
	1990 GMC C3500 Sierra 7.4L Mechanical VIN: 1GCHC34N3L Hey all , Hope you can help with this one. This 454 was replaced by a dealership and hasn't ran right since. The new owner has literally replaced everything. Computer - distributor - throttle body - fuel pump - you name it. When I looked at it, I was immediate...	View
	1998 GMC C3500 Sierra SL 7.4L fuel gauge VIN: 1GDKC34J2W Sweep test with tech 2 gets gauge to respond. Does anyone know what we should see going into and out of balance module (fuel level in & fuel level out circuits)? Gauge shows approx 1/4 tank yet senders indicate nearly full.	View
	2001 GMC Jimmy SLS 4.3L tranfer case VIN: 1GKCT18W11 Good morning to all.I am putting this on here to cover all my bases and I am running out of ideas.Customers complaint is vehicle switches from 2wd to either 4hi or 4lo byitself while driving down the road.I have only comfirmed this once (last week).I have insp...	View
	2006 GMC Sierra 2500 HD SL 6.0L master cylinder VIN: 1GTHC24U76 This truck came in with a braking issue while stopping, from crusing speed the brakes are perfect, dont grab, make any noise or vibration. Just as the truck comes to a stop the pedal drops alittle bit as if the pressure is released somewhere, but the truck sti...	View
	2004 Honda Accord EX 2.4L Poor Idle Quality, Stall, Misfire, MIL Lamp on VIN: 1HGCM55684 With the checks I've done I can see the timing advance is maxed out at 25 degrees, That is the max the VTC can adjust. I've changed the oil and added a flush to try and clean it out. It runs a little better but all 4 cylinders are misfiring and the timing is s... Trouble codes: P1009 (Camshaft position stuck at advanced position), P0341 (Cam position sensor bank 1)	View
	2001 Jeep Grand Cherokee Laredo 4.7L heater core VIN: 1J4GW58N71 I have searched the archives for info on electrolysis and there isn't a single post. Hard to believe. I replaced this core as a preventive measure when I was doing the blend doors last year. Now I have a leak and .45 volts flowing through the coolant. I wonder...	View
	2003 Jeep Liberty Sport 3.7L Compressor VIN: 1J4GL48K63 Have replaced compressor (new OE) and accumulator, also orifice tube. Recharged system but when the clutch engages the compressor, the refrigerant blows out of the back of the compressor under high pressure. Does not blow fuses now. We are thinking bad compres...	View
	2003 Jeep Liberty Sport 3.7L Cuts out VIN: 1J4GL58K93 This jeep is sort of driving us nuts It appears to cut out under load the Injectors shut down and it cuts out 1 sec latter the engine picks up like it lost the RPM signal New Crank Sensor failed to cure this scope on the Crank & Cam looks OK the Injector Pw se... Trouble codes: 300 (random missfire)	View
	2004 Jeep Liberty Sport 3.7L No Start VIN: 1J4GL48K24 Went out to start vehicle and found that I had left the key on. Engine would not start, no crank. Tried boosting battery, no change. attempted to scan for codes and have no communication. I was able to communicate with module earlier, while testing. I'm quite ...	View
	2003 Kia Rio 1.6L Poor Idle Quality, Hesitation, Surge, Cuts out, Stall, MIL Lamp on VIN: KNADC12543 Code P1166 have replaced pcm, maf,checked for intake and vacuum leaks,fuel pump, Trouble codes: P1166	View
	1991 Mercedes-Benz 500SL 5.0L engine VIN: WDBFA66E2M This is a very well maintained vehicle. Owner states engine was running fine when he parked at a store for a short time and when he came out engine would not crank over. Vehicle was towed to our shop and we found that starter would engage and crankshaft would ...	View
	2001 Mercedes-Benz S430 4.3L R-turn signal VIN: WDBNG70J91 Hi all, I have a friend that complains of a very intermintent right turn signal warning that comes up on the dash when he's using the right turn signal, also a rapidly flashing right turn indicator, the car would never do this for me, so I recommended replacin...	View
	2002 Mini Cooper 1.6L abs module VIN: WMWRC33412 I have a 2002 Mini in the shop that has codes for internal error. I checked powers and grounds. There is no can data being transfered. My question is where can i find a abs module for this car. I called Mini they said 900.00 and on national backorder. Does any...	View
	2004 Mini Cooper 1.6L transmission VIN: WMWRC33484 car was fine for a week then problem re-surfaced . I cannot reproduce the issue . re-checked wiring from switch to controller , no problems found . this one has me stumped , any help would be appreciated . I don't want to change the controller if I'm not sure ...	View
	2003 Nissan Altima 2.5L Poor Idle Quality, Surge, Stall, Misfire VIN: 1N4AL11D43 This car came in with a cracked Manifold/Converter. We replaced the Manifold/Converter and the o2 sensor and that fixed the noise issue. After we replaced the Manifold we noticed the car just ran poorly and the customer said it had been running bad for some ti... Trouble codes: P0300	View
	1996 Pontiac Grand Am SE 3.1L temp,tach,speedo,fuel gauge VIN: 1G2NE12M7T Hi Group, I'm in need of your help on my son's car, he went to drive it the other day and the temp gauge, tach, speedometer, and temp gauge were not working. I've tried a used IPC with the same results, a different ignition switch and a different PCM. I've tr...	View
	2003 Saturn Vue 3.0L Misfire VIN: 5GZCZ63B73 Customer came in with vehicle that had codes. Po300 random misfire,[...] #1 misfire,po421 cat eff. low bank 1,p2b03 which I cannot find any info on.I monitored bank 1 o2 sensors and rear o2 mimicing front so I assume cat is faulty.I checked spark plugs and ... Trouble codes: P0300, P2B03, P0421, P0301	View
	2005 Toyota Tundra SR5 4.7L valve train VIN: 5TBRT34115 After identifing the plastic strap in valve train area of cyl#4 I took it out and reinstalled intake. Pulled the plug and looked for plastic, found none but started with plug out to blow anything out. Drove vehicle and condition seemed to improve but went back...	View
	2002 Volkswagen Passat GLS 1.8L Launch Scan Data VIN: WVWPD63B32 I just purchased a Launch X-431 EuroPro and I haveing trouble figuring out the data blocks for the Air Bag system. If I but in data block 001 in comes up with some data numbers on the screen but it does not tell me what the data I am seeing is-if it is system ...	View
	1986 Volvo 740 GLE 2.3L No Forward,Good Reverse VIN: YV1FX8842G Hey guys, need a little feedback to eduacate angry customer!! vehicle came in for ac retro . Small leak noted at compressor. Everything went well and the engine rpm was raised to 1500 for 2 or 3 minutes to improve condensor cooling.ac was fairly cold for a 25...	View
	2000 Volvo V70 2.4L Electronic VIN: YV1LW61J4Y Flashing arrow with all these codes 600 Serial Communication Link 715 Turbine/Input Shaft Speed Sensor Circuit 717 Turbine/Input Shaft Speed Sensor Circuit No Signal 722 Transmission Speed Signal Missing 732 Gear 2 Incorrect Ratio 733 Gear 3 Incorrect Ratio 7...	View

Fixes & Summaries for All Makes and Models

	Fix/Summary	Answers
	2006 Audi A4 Quattro Cabriolet 3.0L Ac VIN: WAUDT48H76 I would like to thank all that resounded to my help request, yes and I would agree that 46 degrees on a hot day is not to bad but he wanted colder. we replaced the compressor,drier and orifice tube we also blocked off the water flow to the heater core, it m...	8
	2007 Audi A4 Cabriolet 2.0L Top VIN: WAUDF48H87 We still are trying to fix this top. But the post has been open to long. We pin checked all the micro switch's and replaced the G 356 position sensor. Readapted the 01 channel but still will only unlatch the top but not retrack or close. Only get this 200 code...	5
	2002 BMW 530i 3.0L Coolant level Sensor VIN: WBADT63481 Thanks for all the replies to all of you. I checked the pass side header tank and it was not there, but it is clear that this car does not have the OBC. So it's safe to say, it never had a level warning system. Thanks again to all.	10
	2006 BMW 325i 3.0L Cuts out, Stall VIN: WBAVB13596 Looks like this one is fixed! Jared got it right. The bolt for the ground wires for the rear coils was loose. Appears the vc gasket was replaced recently. After tightening the bolt, car has run fine. Got to remember to check the simple things first. Thanks to ... Trouble codes: 2E8B.	7
	2000 Buick Regal LS 3.8L MIL Lamp on VIN: 2G4WB52K8Y Come to find out that although I could backprobe the plug and command the vent valve to close for my smoke test, the PCM ground wire going into the plug itself had a break and valve was not closing when system test was occuring. I repaired the wire going into ... Trouble codes: P0440.	15
	2005 Chevrolet Express 2500 4.8L Hesitation, Misfire VIN: 1GCGG25V45 I am a one man operation here and have not had time to close this before now. I replaced cat, and both sensors on bank 2, When got the cat off you see where it had been damaged. This vehicle had a bad coil on this bank recently and thats what contributed to t... Trouble codes: P0300 (missfire).	3
	2006 Chevrolet Silverado 1500 LT 4.8L heater blower VIN: 1GCEK19VX6 WELL I THINK I HAVE THIS ONE FIXED.. I TOOK MOST OF YOUR ADVISE AND REPLACED THE BLOWER MOTOR ALONG WITH A NEW RESISTOR AND AT THE SAME TIME I CLEANED UP THE CONNECTOR SO I GUESS WE'LL SEE WHAT HAPPENS. THANKS TO EVERYONE FOR YOUR ADVISE	11
	1999 Chrysler Intrepid 2.7L mode door VIN: 2C3HH46R0X Thanks so much for all the help. I am lost when it comes to Chrysler stuff. David and Brad nailed it for. A simple calibration after replacing to mode door actuator corrected the air flow concern. THANK YOU. Now I can move this vehicle out and more importantly...	3
	2002 Dodge Ram 2500 5.9L Hesitation, Cuts out VIN: 3B7KF23C72 Wow, all you techs out there know what's up. The fact that it would be intermittent to have turbo boost didn't make sence that it would be the injector pump. I thought for sure I was fighting 2 different issues. I took the advice and disabled the waste gate, s... Trouble codes: P0216.	9
	1999 Ford Windstar LX 3.8L rear lighting VIN: 2FMZA514XX Thanks for your help. Turns out the customer did not want to spend the money to fix the van and after that I forgot to come back and close this out. My apologies for that. He took the van and talked about trading it in. Thanks again for everything. Ron [...]	4
	1999 Ford Explorer XLT 4.0L Excessive Emissions, Poor Idle Quality, Cuts out, Stall, MIL Lamp on VIN: 1FMZU34E2X Thanks to all that replyed. Didn"t fix this one. When we told the customer that he is probably going to need an engine he didn't want to go any further. Said he was going to buy another car. Thanks again. Mark Trouble codes: P0171, P0175.	25
	2002 Ford F-450 Super Duty XL 6.8L Clutch VIN: 1FDXF46S42 Thanks to all who replied. I talked to the owner of the business that has this truck. I showed him your replies, he said just put anouther clutch in it, he would take care of the driver!!! So I can only quess, problem solved. Thanks again! Ken	8
	2003 Ford F-250 Super Duty XLT 6.0L cooling system VIN: 1FTNF21P43 I sent the customer to the local Ford dealership as the motor was under the replacement warranty Thanks to all	6
	2010 Ford Focus 2.0L Hesitation, Surge VIN: 1FAHP3FN2A Thanks for thosw who offered assisance. We replaced the MAF sensor, cleared KAM and road tested to verify repair. Surge and hesitation are now gone. For those suggesting I take this to the Ford dealer, I am currently at the Ford dealership working on this vehi...	7
	1994 GMC K2500 Sierra SLE 6.5L No Start VIN: 1GTGK29F7R Thanks very much for everybody's help.The problem ended up being bad connections in a harness for the relocated PDM that the previous owner had put in and used bare butt connectors and no solder or tape or shrink tube.All is well now.	8
	2004 GMC Yukon XL 1500 SLE 5.3L Previous repair VIN: 1GKFK66U64 Hey Thanks so much! Just wanted ammo for this jerk who is now taking me to small claims court! Guy got handcuffed and arrested last Saturday! Karma is a B*tch! He is bad mouthing me in my town. I am doing a counter suite. I will update after all this crap...	28
	1996 Jaguar XJ6 4.0L Hesitation, Surge, Cuts out, Stall, MIL Lamp on VIN: SAJKN6740T found corroded bulkhead connector beside computer on right hand kickpanel.This bulkhead connector had wiring going into RF fender and up to engine. we repinned this connector which enabled the car to run well enough to realize there was a misfire in the engine...	6
	2003 Kia Optima LX 2.7L Misfire VIN: KNAGD128T3 This was a wild goose chase due to lack of info and crappy ecm programming,checked another kia and there scan data shows bank 2 sensors at zero also so must be the way kia programmed there pids,we had o2 heater action and signals all the way to the pcm just no...	6
	2004 Kia Rio 1.6L MIL Lamp on VIN: KNADC12524 Closeing the throttle plate more seems to have been the cure.Hasnt returned for a couple weeks. Trouble codes: P0121, P0171, P1166.	4
	2005 Kia Spectra EX 2.0L Compressor cycles VIN: KNAFE12135 Thanks for all the replies. I got the cust. back in to test the thermister. The ohms reading should be 8.36k with evap ok. 9.12 with evap too cold. key off it is 3.74 and slowly falling. Unplugged it reads 2.75. key on engine running it reads 5.54k ohms...	6
	2004 Mazda 6 S 3.0L engine VIN: 1YVHP81D04 HI guys thanks for the Tips I believe we got it fixed. When I got back to the shop this morning the coolant pressure had not dropped so I ruled out head gaskets. Then I rechecked the oil and wouldn't you know it was a good half a litre over full. Not to mentio...	10
	2004 Mazda 6 S 3.0L Excessive Emissions, Poor Idle Quality, Hesitation, Cuts out, Stall, MIL Lamp on VIN: 1YVHPB1D34 Dear Members, Unfortunately the Mazda 6 is not fix yet. We still have the car in our shop. We removed front catalytic converter on bank 1. It was completely empty. Beginning of this job, we looked at this by bore scope. It had small crack, but it looked OK. ... Trouble codes: P0172 (System too rich Bank 1), P0443 (Evap purge fault), P0011 (Intake cam too advanced did not return), P0022 (Intake cam too retarded did not return), U0073 (Can Bus Communication off intermittent).	5
	2006 Mazda 5 Sport 2.3L Cuts out, Stall VIN: JM1CR29346 most of the people was right the problem was the purge solenoid. but here is why I got confuse, I remove the valve before I sent the message and the valve looks fine and works when it was energized opening and closing. I install a new sensor and the problem w... Trouble codes: P0455 (evaporative emission control system leak detected gross leak).	16
	2006 Mercedes-Benz S500 5.0L Information Center VIN: WDBNG75J36 As always the vast knowlege of this network is priceless. We've sent the customer to the Mercedes dealer for a new cluster and programing covered by extended warranty campaign. Thanks again and kudos to Chris.	5
	2006 Mini Cooper S 1.6L MIL Lamp on VIN: WMWRE33556 I wish I could add some helpful information, but the code sets so rarely that I am not able to detect any failures. The customer has decided to try the dealer. I was hoping someone may have seen this specific issue before, but I do appreciate those who took th... Trouble codes: P1498 (Air Leakage After Compressor).	4
	2008 Mini Cooper S 1.6L Misfire VIN: WMWMF73588 sorry for long respons time busy with other things. Preformed valvoline 3 step fuel proccess vehicle smoked out a lot of carbon out the tail pipe car has been gone for a week now no problems yet. Thanks to all that respnded Trouble codes: 2783 (combustion misfire decteted), 277B.	4
	2002 Mitsubishi Montero Sport LS 3.0L Misfire VIN: JA4LS21H22 first of all thanks to everyone who replied. after checking the firing order & finding it to be correct i pulled up the wiring diagram & checked the coil connections & found two of them to be crossed. when reinstalling the harness the three wiring connectors f...	6
	2008 Nissan Rogue SL 2.5L blower motor VIN: JN8AS58V88 Sorry for the delay but the blower motor amp. was on back order. That fixed the vehicle a huge Thank You for the replies.	3
	2001 Pontiac Aztek 3.4L gauges VIN: 3G7DA0311S actually some of it is fixed. the owners wants to get rid of it. so we put an ecm in it to make it driveable which it is now. it still has problems with the bcm.	9
	2003 Toyota 4Runner Limited 4.0L fan clutch? VIN: JT2F1779H4 the radiator was stopped with dirt and stuff on the outside so at least one of you guys was right on thanks mark	10
	1995 Volkswagen Passat GLX VR6 2.8L No Start VIN: WVWCC83A1S well it definately helps to have multiple scanners sometimes the first testing was done with a genesys with vehicle specific software later in the day after disconnecting modules was using my modis in generic mode. the car isnt obd2! after receiving response s...	7
	2003 Volkswagen Passat GL 1.8L Cooling Systems VIN: WVWPD63B53 thanks for the repleys dons procedure was realy good i had to take the air valve off to get it out very tight spot was able to move the turbo pipe the o-ring for the housing was bad but i repalced housing cts and thermostate o rings and a broken pcv check valv...	9
	2001 Volvo S60 2.4L High Idle VIN: YV1RS61N81 Hi again, and thanks to everyone that responded. I'm happy to report that the car is fixed. We ended up sending it to the dealer and getting a full system reload of the entire car. The full reload might not have been absolutely necessary, but in this case, we... Trouble codes: ECM62, P0506 (OBDII cross to Volvo code), P0507 (OBDII cross to Volvo code).	5
	2002 Volvo V70 X/C 2.4L Lighting VIN: YV1SZ58D52 thanks for all the replies! The conscenses is to connect the battery with the ignition off. I got the Message board to work again by replacing the bulbs in the back of the cluster unit.but the high beam indictor still didnt work. customer didnt want to look...	6

(Also Available: All, Asian, Chrysler, European, Ford, GM.)