× Auto Repair Pros Member Benefits TechHelp Knowledge Base Forums Resources My iATN Marketplace Chat Pricing About Us Join Industry Sponsors Video Members Only Repair Shops Auto Pro Careers Auto Pro Reviews
Join Now
International Automotive Technicians Network
Prev Professional Automotive Repair Technical Discussions for September 26, 2007
International Automotive Technicians' Network (iATN) - Members Only
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for Chrysler
Help Request Answers
2002 Chrysler PT Cruiser 2.4L Lights VIN: 3C4FY48B42
This vehicle came in as head lights going out intermitently. Could not get it to act up in the shop so we tryed the relay first. Cust. brought it back with no change. replaced the multi funcion switch and it seemed ok for a couple of days. Then back in, hooked...
2005 Chrysler 300 Limited 3.5L front end noise VIN: 2C3JA53G65
i,m hearing a rattle in front of vehicle over slight bumpy road at slow speeds, under 20 mph. have replaced strut, and completely removed front sway bar and links with no results checked and tightened every possible bolt. have checked tsb, and iatn. please hel...
1989 Dodge Shadow 2.5L more power VIN: 1P3BP44KXK
Helllo fellow techs,this is a funny request and please don't laugh too hard so you can't respond.We have the above shadow,we have read in different internet sites that you can advance the cam gear 1 tooth clockwise.This is suppose to get better low end torque ...
1992 Dodge Dakota 2.5L ASD fuse circuit VIN: 1B7FL23G1N
This vehicle came in crank/no-start. ASD fuse blown. With ignition on, red/white wire (ECM pin #3. Main ECM power supply??) develops continuity to ground and blows fuse. Inspection of all underhood circuits and gnds (with harness sheath already removed by owne...
1995 Dodge Ram 1500 5.9L Poor Idle Quality VIN: 1B7HF16Z4S
hello again fellow techs this dodge ram has a funny idle problem. Intermittantly it will drop to a low idle and surge about 400-600 rpm and at times it will go high idle and surge about 900-1200 rpm. We have replaced the IAC and the TPS and the problem went a...
1996 Dodge Caravan ES 3.3L instrument cluster RNDL1 VIN: 1B4GP44ROT
When the indicator lights all light up or are blank van goes into a limp in mode and will not shift.
1998 Dodge Grand Caravan SE 3.3L i/p,headlites,wipers,etc VIN: 1B4GP44R5W
hi, all smarter-than-me-techs! got a dead bus here, 0-300mv on both bus lines, cut bus lines and bcm side both wires is flat ground,3 mv and bus side both wires go to + 2-2.5 v [hash on lab scope]looks like other modules are trying to talk. code p1695 [no comm...
1999 Dodge Ram 1500 Laramie 5.2L Hesitation, Surge, Cuts out, Stall, Misfire VIN: 3B7HC13Y4X
Hey boys and girls. This truck initially came in with a no start condition, through testing we found a plugged converter. We replaced the converter. About a month after it came back with a violent miss, we tuned it up(plugs, wires, cap, rotor, pcv valve, motor...
1999 Dodge Ram 1500 Van 5.2L Differential VIN: 3B7HF13Y5X
has clicking/grinding/vibration noise similar to a bad bearing or bad blower motor. only in two wheel drive. in 4 wheel drive the noise goes away. go back into 2 wheel drive and the noise comes back especially when going over bumps. you can also feel a vibrati...
2002 Dodge Ram 1500 SLT 4.7L No Start VIN: N825650102
Thank in advance for your time and help. Here in the shop we have a Ram truck that we just put a used engine in and it will not start. It keeps setting cam and crank codes without appearent cause.WE dont have a scope yet,I have checked 5V ref & ground to both ... Trouble codes: 1391 (No crank signal at times), 0340 (no cam signal at times)
2003 Dodge Grand Caravan Sport 3.3L Headlights VIN: 2D4GP44313
Greetings, I'm struggling with this one. The customer is experiencing flickering of headlights intermittently. They will flicker four or five times in a row then straighten out for the next 30 miles or so. The customer is concerned they will go out permanently...
1992 Jeep Wrangler 2.5L Cuts out, Stall, Misfire VIN: 2J4FY19P9N
At cruise between 55&65 mph this jeep just falls flat on its face. Seems almost like its running out of gas,or vapor locking or cross fire. Never does completly stall. It runs great untill your up to those speeds. The fuel pressure is good all of the time. On ...
1996 Jeep Cherokee Country 4.0L Poor Idle Quality VIN: 1J4FT78SXT
this jeep will not idle at all please help. We have replaced all the above mentioned parts. I have tested the wires from the computer to the iac valve many times and they are all good no shorts. There is no codes in the computer at all. I can read the scanner ...
1997 Jeep Grand Cherokee Limited 5.2L No Start, Stall, no dash operation VIN: 1J4GZ78Y1V
vehicle will start then stall several times and instrument panel windows and door locks are inop at the same time. try after a few minutes and will start and run fine for as long as you leave it running and the dash is working again. problem will happen 10 tim...
1998 Jeep Cherokee Classic 4.0L steering VIN: 1J4FJ68S1W
after turning either right or left the steering wheel will not return . it will keep going in a circle.

Fixes & Summaries for Chrysler
Fix/Summary Answers
2003 Chrysler Town & Country LX 3.8L Starting VIN: 2C4GP44303
First, Thank You Kent & Thomas [...] The Extra Help. The Van Is Gone. Looks Like The PCM Was The Issue All Along Since Other Than Checking For Shorts Or Lack Of Power On The 5 & 8 Volt Circuits, (That's What The Rebuilders Said Was Blown In The PCM) I Replaced ...
2003 Chrysler Town & Country LXi 3.8L tcm module VIN: 2C4GT54L03
thanks for all the replies the problem ended up being a short in pin #55
1995 Dodge Ram 1500 5.2L low power VIN: 3B7HC13Y1S
hi guys...customer and i reviewed all replies...i had already been suggesting a plugged cat. a 200000 km it was/is due for one...i also know my mistake(see further on)...okay, once the plugs and coil were on for the no start and the crank sensor for the breaki...
2000 Dodge Grand Caravan SE 3.8L timing chain VIN: 1B4GP44LXY
Well i can't find any reason why this would have happened, maybe just a bad chain??, I am waiting for customer to decide if she is fixing this or not, big money for a '00 with 200,000 on it, if she wants it fixed i will give an update on how things worked out
2001 Dodge Caravan SE 2.4L convertor clutch VIN: 1B4GP25B11
I did not see the TCC connector, but after 2 replies said that there was one behind the dipstick tube I found it. I pulled the valve boby replaced the solonoid, cleaned tne valve boby and removed and cleaned governor.There was no evidence of TCC material in fi...
2002 Jeep Grand Cherokee Limited 4.7L crank sensor VIN: 1J4GW58N93
thanks everybody for your help it turned out that the cam sensor was shorting out and since it uses the same 5 volt refrence signal as the crank, the crank wasnt recieving the correct amount of voltage at the moment the engine cranked over and cousing code p03...
Prev (Also Available: All, Asian, Chrysler, European, Ford, GM.) Next