Automotive Technicians Technical Discussion and Fixes for Apr 14, 2006

Join Now

Prev	Professional Automotive Repair Technical Discussions for April 14, 2006 International Automotive Technicians' Network (iATN) - Members Only	Next
(Also Available: All, Asian, Chrysler, European, Ford, GM.)
Vehicle Owners: If you are seeking an automotive repair professional to service your vehicle, visit the iATN Repair Shop Finder.

Open Help Requests for All Makes and Models

	Help Request	Answers
	1987 Audi 5000 CS 2.2L idle too high VIN: WAUHD044XH Hello Everyone, This Audi has come in with an idle of [...]. The idle air valve is good. The idle control unit is good. Both coolant temp sensors are good. When the idle air valve hose going to the intake manifold is pinched the idle goes down. Wh...	View
	1998 Audi A4 2.8L MIL Lamp on VIN: WAUDD28D8W Everytime I think it's fixed the same code comes back! P0411 secondary air injection. I've replaced all the components & I still get the code, I've noticed that just before the light comes on the engine idles rough for just a couple of seconds. As soon as it s... Trouble codes: P0411 (secondary air injection)	View
	2001 Audi A6 Quattro 2.7L abs VIN: WAUED64B71 Recently replaced owner supplied used steering rack-upon replacement ABS light on solid and brake light flashing-checked for codes-had hard codes 00778 steering sensor and 1044 control module incrrectly coded-thinking that we had an incorrect steering sensor w...	View
	2001 Audi TT Quattro 1.8L inst cluster VIN: TRUUT28N51 I have this audi TT that the displays in the instrument cluster such as the clock,odometer and information center constantly blink off and on very fast, also at the same time the needles on the analog gauges bounce back and forth rapidly,and the tach stops wor...	View
	1997 BMW 740iL 4.4L Battery draw VIN: WBAGJ8328V Battery will go flat after sitting 5-7 days. Check of battery draw leaves a 660 mil draw after 15-20 min. Scanned draw with Vantage overnight and it does not change. Remove fuse #6 in engine compartment fusebox will eliminate the draw. Have tried new General m...	View
	2001 BMW X5 3.0i 3.0L Cuts out, Stall, MIL Lamp on VIN: WBAFA53581 car came bach with same problem and code.TIA for your help guys ( boss car ) Trouble codes: 65 (cam sensor inlet or bank 1)	View
	1991 Cadillac Allante 4.5L Unknown VIN: 1G6VS3384M Good morning folks, I have an Allante that will turn on the red brake warning light after starting the car and stepping on the brake pedal. The pedal feels fine and it stops fine also. The code that is setting is 64 (improper plausibility switch fault). The li...	View
	1995 Chevrolet G30 Chevy Van 5.7L No Start, POOR RUNNING VIN: 1GCGG35K9S Van came in no start. I went out to van and took dog house off and cranked it and had spark Van started but ran very poorly for about five minutes and then did not act up again for a week. I eventually found that the right injector was not firing when van ran ...	View
	1996 Chevrolet S10 LS 4.3L Poor Idle Quality VIN: 1GCCT19W7T This vehicle graced our shop several days ago. The customer stated that after having his engine replaced across the mountains his S10 started idleing rough and stumbling on accelleration. Further probing found that he wasn't positive this symptom wasn't presen... Trouble codes: P0300 (Random missfire detected)	View
	1997 Chevrolet Camaro 5.7L Differential trying to install new pinion gear bearings in this posi unit. I have limited experience w/ this rear end. Can't get the carrier assembly removed. Removed carrier bearing caps & nothing. Is there something else holding it in place? any insight or help from you ...	View
	1998 Chevrolet C3500 Cheyenne 5.7L No Start, Stall VIN: 1GCGC33R9W To get right to it, customer complaint is truck intermittently stalls from cruise and takes up to 15 minutes to restart. It has stalled about 4 times in 2 days for me, 3 times at an idle, and once as i was beginning to step on the gas pedal. Will restart immed...	View
	1998 Chevrolet Cavalier 2.2L LR Wheel VIN: 1G1JC1243W Have serviced this rental/loaner car several times and vehicle has had this problem the whole time. Tried disabling ABS to see if problem went away but, no luck. There is no marks on the ID of the brake drum to indicate the linings are hitting the drum. Have t...	View
	2001 Chevrolet Cavalier 2.2L Shudder/Vibration VIN: 1G1JC524X1 I need some help with a Cavalier we have in the shop. The car intermitantly has a shudder at cruise around 55-60 mph. I suspected a misfire but everything checks out OK, i even tried swapping the coils out with know good ones. I also inspected all suspension c...	View
	2002 Chevrolet Silverado 2500 HD 6.6L drive belt VIN: 1GCHC23122 The vehicle came in a few months ago with a belt sqeak. After all the items above had been replaced it still had the noise. We replaced the belt with the factory belt ([...] uzz) and the noise went away for two weeks, but now its back. Using a lazer align t...	View
	2003 Chevrolet Silverado 1500 4.8L brake warning light VIN: 2GCEC19V77 parking brake and abs light come and off.accees abs and found no code.found no exterior leak.no low brake pedal.brake are operating normal	View
	1999 Chrysler 300M 3.5L Poor Idle Quality, Misfire, Poor Fuel Economy, MIL Lamp on VIN: 2G3HE66G8X Hi Guys, This one came in acting as if a major vacuum leak had occured. We can hear what sounds like under the intake manifold but can't swear to it. Although the customer hasn't complained about an oil consumption problem, we did notice that when removing t... Trouble codes: P0300	View
	1988 Dodge B350 5.9L Poor Idle Quality, Hesitation VIN: 2B5WB31W2J Dodge specialist,I have days of testing with no further clues to the problem, and i am desperate for help. The van was driven in to our shop with a complaint of no power, backfiring thru the carb and running horrible. I found a soft collapsed (old rubber) fuel...	View
	1994 Dodge Grand Caravan ES 3.3L left axle seal VIN: 1B4GH54R3R Van came in with a leaking axle seal and bad axle, we replaced axle and seal. Van returned a week later with the seal leaking. We replaced the seal again. Van keeps returning with the same problem. So far we did 5 seals,2 axles, and a bearing and race. We also...	View
	1995 Dodge Intrepid 3.3L transmission control module VIN: 1B3HD46T0S Hi everyone, I need some advice from trans control techs today. What I have is a 1995 Dodge intrepid 3.3 auto that seems to eat TCCM's. This car came to me as no shift, speedo inop, I found no tccm communication and basicly no tccm activity. The cust had repla...	View
	1998 Dodge Ram 1500 Laramie 3.9L Unknown VIN: 1B7HC16X1W i got a 98 dodge ram 1500 3.9l that has codes 1762 gov.pressure sensor offset volts too high. 1763 gov. pressure sensor volts to high. it has no power on take off but ok at highway speeds fluid is full and in pretty good condition. has any one ever seen this ...	View
	2002 Dodge Ram 1500 SLT 4.7L valve train VIN: 3B7HA18N02 vehicle came in with bad miss,found ex side rockers off cyls #3 & 4.rockers & lash adjusters replaced oil changed.[found out quicklube place had put straight 30wt in]vehicle came back later with hydrostatic condition cyl #2 both head gaskets replaced new head ...	View
	1992 Ford Ranger Custom 2.3L No Start VIN: IFTCR10A9N This truck has come in with no spark out either coil pak. There is also no infector pulse present. There has been a new crank position sensor installed as well as a fuel pump relay and main relay. There is power at coils and injectors but no impulse to fire th...	View
	2001 Ford Explorer XLS 4.0L cranking VIN: 1FMYU6CE81 hey guys this is a weird one!!! this exploder came to me from a used car lot. this lot has a reputation for repairing wrecked cars and reselling them. when running, if you turn on the headlights the starter will engauge. or if the car is parked and the engine ...	View
	2001 Ford Mustang SVT Cobra 4.6L Poor Fuel Economy VIN: 1FAFP46V51 the car runs very rich, if i clear the codes 1233 comes instantly back on without starting. if i do a koer test car runs rich and all o2s read rich. when car was running fine o2s also read fine. im leaning towards a pcm, my question has anyone seen this proble... Trouble codes: 1233 (fuel system disabled no communication from fpdm)	View
	2002 Ford Ranger XL 4.0L MIL Lamp on VIN: 1FT2R45E22 The car came in with a MIL for P0457 Checked fuel cap and found aftermarket replaced cap and sent customer home.A week later car came back with same code checked system for leaks with evap smoke machine. None found also checked both solenoids Vapor managment v... Trouble codes: P0457 (Check For Missing Or Leaking Fuel Filler Cap)	View
	2003 Ford Ranger Edge 4.0L 2nd gear and 4th or possibly 5th gear VIN: 1FTZR45EX3 This vehicle came in and when it would get hot it would slip in reverse. The customer requested that it be rebuilt. After rebuiling it I installed it back in the vehicle only to find that when it shifted out of 1st it went straight to third, then acted like it...	View
	1998 Jeep Cherokee Classic 4.0L Hesitation, Cuts out, Stall VIN: 1J4FT68S5W Hi. This is my first post. This Jeep came to us with the complaint that after long highway trips, like 1-2 hours it will cut out. His discription was just losing speed. After sitting off the road for 5-10 minutes. It would always re start and run fine. Says it...	View
	2001 Jeep Grand Cherokee Laredo 4.0L No Start VIN: 1J4GW48591 we tried a coil pack,no change.checked compression,#3 cylinder had 0 compression,others were between 150- 170 psi.aired up the cylinder and slight amount of air came out form intake,loosened the rockers and the air stopped.we replaced the cylinder head and lif...	View
	2002 Mazda MPV EX 3.0L oil light on dash VIN: JM3LW28J72 First off I'd like to say thanks for any help received, this one is annoying in that I have a feeling it would be easy to diagnos if the problem would ever actually happen for us. The customer states that the oil light on the dash is flickering on and off ever...	View
	2000 Mercedes-Benz C230 Kompressor 2.3L Misfire, MIL Lamp on VIN: WBDHA24G7Y Hi MB-Experts & Fellows ! Car came in with request to change supercharger (noisy !) & tune-up with spark plugs.Also brake fluid flush & transmission flush.Car came from the local MB dealer. But cust. may didn't tell the whole story why car was in by dealer. Af... Trouble codes: P0300 (Misfiring demages TWC fault indicator lamp on), P0243 (air flap switchover actuator for compressor M167 current stored)	View
	1996 Mercury Mystique GS 2.0L alternator VIN: 1MELM653XT car Came in with a battery drain. after testing it was found that the battery cables and all wiring from battery to main fuse block were destroyed by battery acid. after replacing all wiring and cables the drain was repaired. but the alternator will not energi...	View
	2000 Mitsubishi Mirage DE 1.5L MIL Lamp on VIN: JA3AY11A4Y this is a good one! vehicle cam in with mil on and a p0170 stored in memory. ect , iat , map all look normal.took vehicle out and drove down the highway about five miles. at highway runs excellent fuel trims normal hovering around zero. at idle and on decel is... Trouble codes: P0170 (fuel trim malfunction bank 1)	View
	2001 Mitsubishi Galant ES 2.4L Misfire, MIL Lamp on VIN: 4A3AA46G01 Car came in about 5 weeks ago. Had random missfire code. We replaced the spark plugs and the plug wires and coil boots. Car seemed to work fine. It came in once after that with p0300 and the freeze frame data showed 85% load and about 5000rpm. A kid was drivin... Trouble codes: P0300 (Random missfire)	View
	2000 Pontiac Bonneville SE 3.8L ride control hi fellow techs,i have a problem with this ride control.the pump runs most of the time with key on.will air up rear shocks,then they'll stay up-no leaks.sometimes it will release and lower shocks to normal ride hieght.sorry for the vague request,but i will be ...	View
	2001 Pontiac Grand Am SE 3.4L No Start VIN: 1G2NF52E21 this ones a hair puller, has spark, fuel press, plugs are dry, will run on carb cleaner, suspect no pulse to injectors, crank and cam genrators have been changed, 50 -psi fuel press, kinda lost on this, thanks for any and all imput.	View
	1999 Porsche 911 Carrera 3.4L dome/map lights VIN: WPOCA2992S Hello porsche techs. This 911 convertible has no dome/map/door lights. When the ignition key is turned on, lights then work normally. All fuses are good. Alldata has no diagnostic information on it. All I got back from them was a wiring diagram. Appears that p...	View
	1993 Saab 900 S 2.1L running lights VIN: YS3AK75E1P This car came in with the left side running lights staying on all of the time, became a intermittent problem before any testing could be performed, have test driven several times and miles and light will stay on from 1 min to 2 hrs Tested the headlight switch,...	View
	1997 Subaru Legacy Outback 2.5L Mechanical VIN: 4S3BG6850V This is really bothering us... We are paying careful attention to the install of the cam and crank seals and we have also replaced the oil pump seals as a preventive measure. The PCV Valve has been replaced with no signs of blockage. This is one of several of ...	View
	1995 Toyota Land Cruiser 4.5L Steering VIN: JT3DJ81W1S Hi guys this land cruiser has a steering wheel that chatters or binds when turning at stops if you raise the idle it gets alot better, almost goes away if you raise the truck problem completely goes away. On the road its fine. So we put A new P.S. pump in it a...	View
	1998 Toyota Avalon XL 3.0L Surge, MIL Lamp on VIN: 4T1BF18BXW Customer complaint mil on, surge while driving. I watched the egr postion sensor output and was suprised to see it reflect the valve fully open and slam shut about once per second while driving. Yea it surges alright. Looked at the vsv for egr and found the ec... Trouble codes: P1411 (EGR position sensor)	View
	2001 Toyota Sienna LE 3.0L cooling system VIN: 4T3ZF13C71 Van came in with complaint temp guage runs hot,inspected system,no leaks,fans operational,although i'm not sure how many speeds it has.We replaced t-stat again,headgaskets,inspected water pump,still overheats.Any ideas would really be appreciated,this is a tou...	View
	1998 Volkswagen Beetle 2.0L Poor Idle Quality, Cuts out, Stall VIN: 3VWBB61C8W vehicle came in barley running. found the brake booster vaccum lines cracked. replaced them. found #1 spark plug wire shorting out. replaced plugs and wires. chk compression while i had the intake off and found compression was 175-180 psi on all cylinders. ohm... Trouble codes: P0134 (bank 1 sensor 1 no activity detected), P0300 (random misfire), P0301 (cyl 1 misfire), P0303 (cyl 3 misfire), P1128 (bank 1 lean)	View
	1999 Volvo S80 T6 2.8L Oil Leak VIN: YV1TS90D7X Hi, This Volvo is driven by a little old lady who must never really get on it. Whenever we road test the car and really get the boost going, it will blow the engine oil dipstick out of the dipsitck tube and allow oil to leak on to the top of the engine. I sus...	View

Fixes & Summaries for All Makes and Models

	Fix/Summary	Answers
	1993 Audi 90 S 2.8L Base Cam Shaft Settings VIN: WAUDJ58COP Hello and thanks to each man who wrote to offer their help. The answer is that this engine is setup on TDC on # 3 cylinder. That is to say that both the piston and the engine valves are set to the firing position for # 3. Here is the set of steps that on...	12
	1998 Buick Skylark Custom 3.1L switch VIN: 1G4NJ52M02 we fix the car. thanks for all the help. WE HAD THE HEAD LIGHT CONNETIONS AND FOR THE RUNNING LIGHTS DIDN'T MATTER THE POLARITY, SINCE IS ONLY A BY PASS.	5
	1995 Chevrolet Caprice Classic 5.7L Fuel pump VIN: 1G1BL52P7S Hello everyone,As I stated in my original post the car isn't driven much because he is trying to sell it.Anyway the car is still here and is still starting every morning,every lunch break,and every evening when we drive it in. We got some helpfull sugestions w...	28
	1996 Chevrolet Astro 4.3L Intake manifold VIN: 1GNEL19W8T Thanks for the great response everyone. We fixed this car and used the Fel-pro gaskets like many folks reccomended. The kit included the valve cover gaskets so they were also replaced. The heater valve broke when we removed a hose so that was replaced. We used...	39
	1999 Chevrolet Silverado 1500 5.3L No Start, Stall VIN: 1GCEK19T5X it was the vehicle theft sensor in steering column. thanks for all the replies. good to know everybody thinking same direction i was. what got me was when called dealer with vin# they said did not have antitheft. that's what i was thinking when the other shop ...	28
	1999 Chevrolet Astro 4.3L Spider Gears VIN: 1GNDM19W2X Thanks Techs. Nothing really unusual about the repair or the condition of the gears. Just as some of you said, maybe just a tad too small a rearend for this vehicle since it also serves as a trailer towing vehicle. Replaced side and spider gears. Used stock sh...	10
	2000 Chevrolet Venture 3.4L alt VIN: 1GNDX03E0Y thanks to all who replied. well the fix was you guessed it/ an ac delco alternator. after the responses of aftermarket junk my boss said to go ahead and put one on it. if it was up to me all parts would come from the dealer. thanks again	13
	2001 Chevrolet Silverado 2500 HD 8.1L trans data VIN: 1GCHK29GX1 First of all thanks to all that have responded. It turns out that this vehicle had a couple of problems. 1st problem was that it had a snow plow electrical harness at the battery that was inbewtweeen the oe electrical harness so all vehicle power was going thr...	5
	2006 Chevrolet aveo 1.6L Stall Thank you all for your replies. I was sent to training the next day and the car was given back to the customer. And it has not returned yet. but if it does i will update the post.	4
	1993 Dodge Intrepid ES 3.5L No Start, Hesitation, Cuts out, Stall, Misfire VIN: 2B3ED56F4P Hey guy thanks for all the help every one was right on this one the crank sensor was bad but also when we changed trannys in this car the timeing belt had slipped a tooth we put a new timeing belt and a new water pump on it again thank you for all the help guy...	40
	1996 Dodge Stratus 2.4L No Start, Stall, Misfire, MIL Lamp on VIN: 1B3EJ46X3T Thank you for your help. The car is fixed. I found that cleaning the small ground connection next to the main battery ground on left strut tower cured the ac voltage problem and the battery light. I installed new fuel pump which took care of the stalling and n... Trouble codes: 46 (battery voltage too high), P0300 (misfire), P0304 (cylinder 4 misfire).	3
	1997 Dodge Grand Caravan ES 3.3L OD Clutch VIN: 1B4GP54R1V Hello, Thanks for the replies. I pulled this unit down and OH it. Cause of runaway neutral was stripped splines in the front planet where the OD shaft splines to the carrier. The splines on the OD hub/shaft were kinda pissed off, but still intact. The spline...	7
	1998 Dodge Ram 1500 Laramie 5.2L abs motor VIN: 3B7HC16Y7W well i installed new module assy, was only about 400. reprogrammed module with my midis for tire size and axle ratio, works great, thanks for your help.	4
	1994 Ford Thunderbird LX 4.6L Poor Idle Quality, Cuts out, Misfire VIN: 1FALP63WXR wow thanks to all who replied. yes the noid light stayed solid. ohmed the wire, tested ok. replaced computor and it runs great. thanks we were stumped. the car test drives perfect.	8
	1996 Ford F-250 XL 7.3L Stall, Poor Fuel Economy, MIL Lamp on, NO POWER VIN: 1FTHW26F3T thank you to bill [...],, and rusty savignoc.. our main concern had been lack of power , truck never started to stall on us untill we had had truck for about a week , installed cam sensor and stalling problem stopped and increase... Trouble codes: P0472 (exh press sensor low), P0344 (cam sensor), P0470 (exh back pressure circuit malfunction).	5
	1997 Ford E-250 Econoline 5.4L Cuts out, Misfire VIN: 1FTFE24L8V carbon build up in the clys was the problem. we ended up running top engine cleaner through the intake twice and did fuel injection cleaning twice. customer came back yesterday with a different problem and said it was running fine. sorry it took so long to clo...	10
	2004 Ford Ranger Edge 3.0L Excessive Emissions, Poor Idle Quality, Misfire, MIL Lamp on VIN: 1FTYR10U64 THANK YOU very much to all the respondents we pulled head and sure enough valves are sunk in head Mike in Ga. was right about update heads $400 each from dealer local machine shop installed new seats.I guess we allowed our selves to second guess what was obv... Trouble codes: P0316, P0304, P0305, P0306.	7
	1996 GMC C1500 Sierra SL 5.7L Rear brakes VIN: 1GTEC19RXT FIXED...The darn truck was being a VENTRILOQUIST!!! And I was the dummy!!! The truck has a campershell. Three of us (we took turns) rode in the back of the truck while another tech drove the truck. The sound & vibration we all agreed was felt & heard in the le...	18
	2001 GMC Jimmy SLE 4.3L MIL Lamp on VIN: 1GKDT13W31 thanks for your replies after checking the check valve operation we found that the tech that installed the pump switched hoses Trouble codes: P0410 (secondary air problem).	5
	2001 GMC Jimmy SLE 4.3L cannot fuel vehicle VIN: 1GKCS13W71 We recieved many replies, many said pull the tank & check for restrictions, or foreign objects inside. We replaced the tank, found that the forward vent/check valve which is made into the tank (not servicible) was hung up & would not allow air to flow in eithe...	11
	1997 Honda Accord LX 2.2L code p1705 VIN: 1HGCD5639V Several people wrote to me and warned that any alarms, etc. that were installed in the car by aftermarket companies can seriously affect this system. There were none in the car. This code is set when the trans sees the gear selector indicating two gears at onc...	6
	2000 Honda CR-V EX 2.0L 1-2 shift VIN: JHLRD1867Y Thanks for the help. I think the vehicle was poorly maintained which led to this problem. The trans fluid was drained out and refilled with correct honda fluid. No change. As suggested by Jeff we removed , checked function and cleaned the solnoids to no avail....	7
	2001 Hyundai Santa Fe GLS 2.7L speedo VIN: KM8SC83D51 After waiting for about 2 weeks, I finally received new drive gear. It is approx 1.5mm larger OD. The new drive gear fitts on carrier very tight, no slop at all. With new drive and driven gear (new one approx 1mm larger OD) installed the speedo works perfectly...	3
	1994 Jeep Cherokee Country 4.0L rear brakes VIN: IJ4FJ27S4R thanks for all the advise! well jeep is out the door and stopping. this vehcile DOES NOT have abs nor weight adjusting valve, just the basic brake system. after rechecking everything we found that the drums were out of specs at maxium allowed diameter. Brake h...	13
	1999 Jeep Cherokee Sport 4.0L not sure VIN: 1J4FF68SXX Replaced high pressure cutoff to repair problem. Thanks for all your help	18
	1999 Lexus GS300 3.0L Pump VIN: JT8BD68S6X Based on cost we are in the process of replacing the entire ABS unit with a used piece. Since there are not too many posts regarding this, I don't consider it a pattern failure and feel confident the used unit will fix it. We got the whole thing, master cyl, p...	4
	1974 Mercedes-Benz 280C 2.7L a/c blower VIN: 1140731210 Well I would like to thank everyone for their replies, especially Bill from Virginia. The problem wasn't as complicated as it seemed, We assummed the Change over Valve was working because it was turning on the A/C Compresser but as we found out by Bill's sugge...	9
	1998 Mercedes-Benz SLK230 Kompressor 2.3L MIL Lamp on VIN: WDBKK47F5W After lots of phone calls to Robert [...] and his collegue, we came to the conclusion that the MAP sensor was probably at fault since it is the primary sensor in the logic chain to control the variable cam timing. I monitored the MAP reading at idle and obs... Trouble codes: P0809, P0410.	6
	2005 Mercedes-Benz C240 4Matic 2.6L Accessories VIN: WDBRF81JX5 This car can NOT be reset with the dashboard method. I would dearly like to speak with someone who has done so, for I was not able to use the standard methods. My local dealer was of little help, offered only that the unit had to be reset via the Mercedes to...	13
	1993 Mercury Sable LS 3.0L Excessive Emissions VIN: 1MELM53U3P Thanks so much for the info. on this sable. Replies that i recieved all pointed to the pfe sensor. After inspecting sensor seemed to be ok but found the down pipe to exhaust manifold cracked. Replaced both the sensor and the flex down pipe and all is well. Tha...	6
	2001 Mercury Grand Marquis GS 4.6L Poor Idle Quality, Misfire, MIL Lamp on VIN: 2MEFM74W01 I cleaned the injectors customer is going to try it for a few days if not fixed I will change the # 5 injector thanks for the help EVERYONE !!! Trouble codes: P0305.	17
	1996 Nissan Maxima SE 3.0L Surge, Misfire, MIL Lamp on VIN: JN1CA21DOT This one was not ment to be for me. Thanks for the 3 replies . The customer picked up the car unfixed. I guess I cant fix them all. This has no tbelt and has no distbutor. I felt it was a coil issue or possible ecm. Since I have no way of scopeing all the coil... Trouble codes: P0340, P0325.	4
	1997 Oldsmobile Bravada 4.3L Chassis VIN: 1GHDT13W0V Sadly the only fix we could find was to replace the transfer case with a used one,it was a gamble but it worked.Still don't know what the problem with the rebuilt transfer case was!	5
	1990 Toyota Camry 2.0L No Start VIN: 4T1SV24E3L well yes its fixed thanks to the guys that said check grounds but it was not a grounding problem but a short to ground i found an injector wire pinched to ground i repaired the wire and now the car runs fine Trouble codes: 41 (throttle position).	12
	1995 Toyota 4Runner SR5 3.0L rear differential VIN: JT3VN39WXR The drivers side axle was bent. The pinion shaft had a slight groove in it. Sent axle off to be straightened and used a pinion saver on the pinion. Test drove a long way put back on rack and no leaks when truck left shop. Thanks a bunch for all your ideas of w...	9

(Also Available: All, Asian, Chrysler, European, Ford, GM.)